360Û SWING LOCK
DO NOT ENGAGE 360Û SWING LOCK WHILE SUPER-
STRUCTURE IS IN MOTION.
CAUTION
80117046
INSIDE GLASS
IN CLEAR VIEW
OF OPERATOR
CAUTION
PIN SWING LOCK
Do not engage Pin Swing Lock while
superstructure is in motion. Center boom over
front and engage Pin Swing Lock to prevent
rotation during travel.
7376011340
UNLOCK
LOCK
PIN
SWI N G
LOCK
80026772G7
PULL
PUSH
80064053EN
PATENT INFORMATION:
https://ir.manitowoc.com/investor-
relations/resources/Intellectual-
Property
Be sure outriggers are properly extended and set and
crane is level for operation on outriggers.
All four outrigger beams must be equally extended to
the appropriate vertical stripe before beginning
operation.
All four outrigger beam lock pins must be engaged
before operating from the mid-extend position.
Operator must select proper load chart and RCL
program for the outrigger position selected.
7376007441
DANGER
ELECTROCUTION HAZARD
TO AVOID DEATH OR SERIOUS INJURY
Keep ALL parts of the crane, rigging and load at
least 20 feet (6 meters) away from any energized
power line. You MUST follow the OSHA require-
ments set forth in 29CFR 1926.1407 through
1926.1411.
This crane is not designed or equipped for use
within 10 feet (3 meters) of energized power lines
[Refer to 29CFR1926.1410 Table A]. If operation
within 10 feet (3 meters) or any power lines cannot
be avoided, the power utility MUST be notified and
the power lines MUST be de-energized and
grounded BEFORE performing any work.
If contact is ever accidentally made with a power
line and any part of this crane, its rigging or load,
NEVER touch the crane or even approach or come
near the crane.
Electrocution CAN OCCUR even without direct
contact with the crane.
G7 80041097
G7
80034750
CAUTION
TRANSMISSION DAMAGE
To prevent transmission damage: shift
between 2-wheel and 4-wheel drive only
with crane stopped and transmission in
neutral and service brake applied.
7376100080G7
CRUSHING HAZARD
DEATH OR SERIOUS INJURY COULD RESULT
FROM BEING CRUSHED BY MOVING
MACHINERY.
Before actuating swing or any other function,
sound horn and verify that all personnel are
clear of rotating and moving parts.
DANGER
EMERGENCY EXIT
IN EMERGENCY,
PUSH OUT WINDOW
AND ESCAPE
THROUGH OPENING.
7376009502
CAB WITH STEERING COLUMN AND SEAT REMOVED
KEEP DECALS AT LEAST 2” ABOVE CAB FLOOR
KEEP DECALS AT LEAST 2”
ABOVE CAB FLOOR
CAB SECTION VIEW
CAB OUTSIDE REAR VIEWBEHIND CAB SEAT
80113724 B5
SINGLE AXIS DUAL AXIS
NO STEP
7376007370
SEAT BACK MUST BE IN FULL UPRIGHT
POSITION AND LEFT ARMREST MUST BE
ROTATED BACK TO NON-OPERATIONAL
POSITION BEFORE ENTERING OR
LEAVING CAB.
7376009507
CAUTION
1
1
G7 80117002
2
2
G7 80077416
80117009
MODEL
SERIAL
Grove U.S. L.L.C.
P.O. BOX 21, SHADY GROVE, PA 17256, U.S.A.
7679100089
MFG. DATE
MODEL YR.
DANGER
7376102946
To avoid death or serious injury:
Never mix gasoline, alcohol, or gasohol
with diesel fuel. This mixture can cause
an explosion.
G7
Use only ultra low sulfur fuel. Failure to
do so may cause damage to the catalyst.
80127103
TELESCOPE BOOM OUT
TELESCOPE BOOM IN
BOOM UP
BOOM DOWN
REAR WHEELS
NOT CENTERED
IGNITION "ON" AND/
OR VOLTMETER
ENGINE RPM
HORN
ENGINE TEMPERATURE
DRIVE LIGHTS
PARK LIGHTS
ENGINE STOP
LOW FUEL LEVEL
LOW BOOM INDICATOR
WORKING RANGE LIMITER
TELESCOPE CYLINDER AT
BOOM NOSE INDICATOR
TRANSMISSION
WARNING
TRANSMISSION
TEMPERATURE WARNING
CRANE FAULTS
P
BOOM LIGHTS
WINDSHIELD WASHER
WORK LIGHTS
SKYLIGHT WIPER
SWING BOOM RIGHT
SWING BOOM LEFT
WAIT TO START
TELESCOPE SEMI-AUTO
TELESCOPE MANUAL
TELESCOPE EMERGENCY
TELESCOPE UNKNOWN
CAB POSITION INDICATOR
2 WHEEL DRIVE
4 WHEEL DRIVE
CAB HEATER ON
DISABLE REGENERATION
OUTRIGGER JACK
OUTRIGGER BEAM
OUTRIGGER EXTEND
OUTRIGGER RETRACT
REAR STEER
TURNING RIGHT
REAR STEER
TURNING LEFT
AUXILIARY HOIST UP
ENGINE DECREASE/
PUSH TO STOP
ENGINE INCREASE/
PUSH TO START
AIR CONDITION
AUXILIARY HOIST DOWN
MAIN HOIST UP
MAIN HOIST DOWN
DIFFERENTIAL LOCKED
PARK BRAKE RELEASE
PARK BRAKE ENGAGED
HAZARD LIGHTS
P
P
CRANE FUNCTION
POWER ON/OFF
3 WRAPS ON HOIST
DISENGAGED/OFF
LAMP MALFUNCTION
LOW STEER
PRESSURE
LOW BRAKE
PRESSURE
HYDRAULIC
OIL HIGH TEMP
DIESEL PARTICULATE FILTER
EMERGENCY STOP
DIESEL EXHAUST FLUID
HIGH EXHAUST
TEMPERATURE
STOP
STOP
ENGINE WARNING
STOP
CAB TILT UP
CAB TILT DOWN
LUFFING EXTENSION
SWING BRAKE RELEASE
G7
3
1
1
2
2
80125592G7
SEAT CONTROL
FACING OPERATOR
80125592G7
SEAT CONTROL
F1 - 10A - CAB WORK LIGHTS
F2 - 5A - E-STOP SWITCH SIGNAL
F3 - 5A - BOOM MOTORIZED WORK LIGHTS
F4 - 5A - ACCESSORY LIGHTS
F5 - 5A - MAP LIGHT & USB POWER
F6 - 10A - RADIO IGNITION POWER
F7 - 3A - SYSTEM WAKE-UP
F8 - 3A - KEY SWITCH SIGNAL
F9 - 5A - CIRCULATION FAN
F10 - 15A - HEATER / AC SWITCH POWER
F11 - 5A - DOME LIGHT
F12 - 5A - WINDSHIELD WASHER RELAY FUSE POWER
F13 - 10A - HEATED SEAT POWER
F14 - 10A - UE+ T/T CCM10/IOL45/IOS20 MODULE BATTERY
POWER
F15 - 5A - RADIO / CRANESTAR BATTERY POWER
F16 - 5A - UE+ CAB SCMO/IOL32 MODULE BATTERY POWER
F17 - 20A - OIL COOLER POWER FAN 1
F18 - 20A - OIL COOLER POWER FAN 2
F19 - 15A - UB+ T/T IOL45 POWER
F20 - 15A - UB+ T/T IOL45 POWER
F21 - 10A - UB+ IOL32
F22 - 3A - B+ TO KEY SWITCH
F23 - 10A - SKY LIGHT WIPER
F24 - 10A - WINDSHIELD WIPER POWER
F25 - 5A - SKY LIGHT WASHER RELAY FUSE POWER
F26 - 15A - UB+ T/T CCM10
F27 - 15A - UB+ T/T CCM10
F28 - 20A - 24V SUPPLY 12V-DC CONVERTER
F29 - 15A - UB+ IOS20 / UE/UB+ IOS21
F30 - 5A - DIAGNOSTIC CONN POWER
F31 - 10A - UB+ IOL32
F32 - 20A - ACTUATOR 1, 2, & 3 RELAY FUSE POWER
F33 - 5A - DISPLAY / JOGDIAL RELAY FUSE POWER
F34 - 5A - FUSED B+
K1 - WINDSHIELD WASHER RELAY
K2 - SKY LIGHT WIPER RELAY
K3 - SKY LIGHT WIPER LOW
K4 - WINDSHIELD WIPER HIGH
K5 - WINDSHIELD WIPER RELAY
K6 - SKY LIGHT WIPER HIGH
K7 - WINDSHIELD WIPER LOW
K8 - ACCESSORY RELAY
K9 - OIL COOLER RELAY
K10 - SKY LIGHT WASHER RELAY
K11 - ACTUATOR 2 (IN) RELAY
K12 - ACTUATOR 1 (OUT) RELAY
K13 - ACTUATOR 3 (IN) RELAY
K14 - ACTUATOR 2 (OUT) RELAY
K15 - ACTUATOR 1 (IN) RELAY
K16 - ACTUATOR 3 (OUT) RELAY
K17 - DISPLAY / JOGDIAL RELAY
K18 - HORN RELAY
K19 - ACTUATOR ENABLE RELAY
X1 - BATTERY DISCONNECT SWITCH POWER WIRE 1274
X2 - BATTERY DISCONNECT SW POWER WIRE 6
X3 - BATTERY DISCONNECT SW POWER WIRE 5
X4 - GROUND
F1
F2
F3
F4
F5
F6
F26
F27
F28
F29
F30
F31
F32
F33
F34
F16
F17
F18
F19
F20
F21
F22
F9
F10
F11
F23
F24
F25
K1
K2 K3
A
B
C
K8
K4
K5 K6
K10
K7
K11 K12 K13
K14 K15
K19
K9
X1 X2 X3
K17
K18
D5
K16
F7
F8
F14
F15
F12
F13
X4
D1
D4
D2 D3
CAB FUSE AND RELAY BOARD
80125248G7
5
5
3
3
5
5
10
5
10
20
15
15
20
15
20
20
5
10
15
15
10
3
5
15
5
5
10
10
19
10
1
25
18
9
9
18
25
1
10
19
19
10
1
25
18
9
10
5
5
5
5
10
9
8
7
10
8
7
111
110
101
115
120
FACING OPERATOR
120
5
20
6
106
23
12
SURFACE
ON TOP
109
116
104
107
112
118
117
24
29
102
105
103
406
404
FIGURE A-1 continued
10087-5
To Next Page
Loading...
Need help?
General
