THE NEW PIPER AIRCRAFT, INC.
PA-32-301FT / 301XTC
MAINTENANCE MANUAL
PAGE 2
Feb 19/04
1B2
INDEX
Electrical System
Description and Operation:
2F19
Load Distribution: 2H9
Troubleshooting: 2F19
External Power: 2H7
Overvoltage Relay Check: 2H3
Schematics
Air Conditioning: 5I1
Alternator Power: 5I5
Ammeter: 5I7
Annunciator: 5I21
Baggage Door Ajar: 5J4
Baggage Light: 5J5
CHT: 5K1, 5K5
Clock: 5J5
Courtesy Lights: 5J9
Data Acquisition Unit: 5K8
EGT: 5K6
Engine Combination Gauge:
5K1
Engine RPM: 5J23, 5K3
Exceedance Audio Alert: 5J4
External Power: 5I9
Flood Lights: 5J7
Fresh Air Blower: 5H23
Fuel Flow: 5K6, 5K7
Fuel Pump: 5I15
Fuel Quantity: 5I17
Hour Meter: 5J5
Landing/Taxi Light: 5J15
Low Volt Monitor: 5I7
Magneto Switches: 5J21
Manifold Pressure: 5K3
Navigation Lights: 5J16
Oil Press: 5K1, 5K4
Oil Temp: 5K1, 5K4
Panel Lights: 5J12
Pitot Heat: 5I19
Power Point: 5I11
Radio Lights: 5J11
Radio Master Switch: 5I3
Reading Lights: 5J9
RPM: 5J23, 5K3
Stall Warning: 5I13
Standby Attitude Indicator:
5J18
Starter: 5K11
Strobe Lights: 5J16
Switch Lights: 5J8
Tachometer: 5J23
TIT: 5K7
Turn and Bank Indicator: 5J17
Static Wicks: 2F11
Symbols: 5H18
System
Servicing: 1I12
Voltage Regulator Check: 2H3
Wire Coding: 5H17
Electrical/Electronic Component
Alphabetical Index: 4C11
Locator Illustration: 4C12
Electronic Flight Display System
(EFDS)
Component Locator: 3L11
Description: 3L9
Magnetometer: 3L13
Maintenance: 3L10
OAT: 3L13
Standby Attitude Indicator: 3L13
Wiring Harness: 3L15
ELT
Artex ELT 110-4: 2I1
Battery: 2I1
Testing: 2I2
Wiring Schematic: 2I3
Empennage Installation: 4F4
Engine
Cowling: 4J1
Description: 4I13
Exhaust - See Exhaust System
Fuel
Air Bleed Nozzles: 4J15
Injection System: 4J17
Injector: 4J15, 4J18
Installation: 4I19
Instruments: 5D21
CHT Gauge: 5E3
EGT Gauge: 5E1
Manifold Pressure Gauge:
5D23
Oil Pressure: 5F3
Oil Temperature: 5F4
Tachometer: 5D23
Lubrication
Changing Oil: 1I3, 1I4
Chart: 1I24
Oil Filter: 1I4
Oil Screen: 1I4
Oil Sump: 1I3
Mount: 4J3
Corrosion Inspection: 4J4
Installation: 4J5
Oil Cooler: 5F1
Serial Number Location: 1F1
Standard Practices: 4I5
Starter: 5F13
Bench Tests: 5F16
Inspections: 5F14
Service Test Specifications:
5F16
Troubleshooting: 5F14
Using External Power
Receptacle: 5F17
Throttle and Mixture Controls
Adjustment: 4J21
Timing Marks: 5C9
Troubleshooting: 4I13
Turbocharger
Decoking: 5G10
Description: 5G1
Installation: 5G8
Nomenclature: 5G4
Troubleshooting: 5G2
Wastegate: 5G10
Adjustment: 5G11
Installation: 5G11
Exhaust System
100 Hour Inspection: 5E13
Inspection Points - 6X: 5E14
Inspection Points - 6XT: 5E15
External Power
Contactor: 4C13
Installation: 4C13
F
Fiberglass Repairs - See Repairs -
Fiberglass
Flaps
Control System: 2K19
Installation: 2K20
Rigging and Adjustment:
2K22
Troubleshooting: 2K19
Installation: 4H2
Torque Tube/Pushrod Distortion
Inspection: 2K24
Flareless Tube Assemblies: 1J16
Flight Controls
Ailerons - See Ailerons
Control Cable Inspection: 2I14
Description and Operation: 2I11
Flaps - See Flaps
Lubrication Chart: 1I22
Rudder - See Rudder
Stabilator - See Stabilator
Standard Practices and
Procedures: 2I11