Section 01 MAINTENANCE
Subsection 01 (MAINTENANCE CHART)
10-HOUR OR 500 KM (300 mi) INSPECTION (to be performed by dealer)
A: ADJUST
WEEKLY OR EVERY 240 KM (150 mi)
I: INSPECT
MONTHLY OR EVERY 800 KM (500 mi)
L: LUBRICATE
ONCE A YEAR OR EVERY 3200 KM (2000 mi)
R: REPLACE
6000 KM (3700 mi)
C: CLEAN
STORAGE (to be performed by dealer)
T: PROCEED WITH TASK
PRESEASON PREPARATION
(to be performed by dealer)
SYSTEM
REFER TO SECTION(S) AND
SUBSECTION(S)
Drive axle end bearing
(2)
L L L 06-07
Countershaft
(2)
L L L 06-07
Track
I I I 06-08
Track tension and alignment A
AS REQUIRED
06-08
STEERING/FRONT SUSPENSION
Steering and front suspension mechanism
(2)
I,L I L I,L 08-01 and 08-02
Wear and condition of skis and runners
I I I 08-02
SUSPENSION
Suspension adjustments
A
AS REQUIRED
Suspension
(2)
I I,L I,L
Suspension stopper strap
I I
Section 07 or 08, see the
appropriate subsection
ELECTRICAL
EMS fault codes
(4)
I I 04-03
Spark plugs
(1) (4)
I I R 05-01
Battery (if so equipped)
I I I I 05-02
Wiring harnesses, cables and lines
(4)
I I I 09-01
Operation of lighting system (HI/LO beam, brake light, etc.)
test operation of engine cut-out switch and tether cut-out
switch
I I I
Operator’s Guide and/or 05–05
VEHICLE
Headlamp beam aiming A A 05-04
Engine compartment C C C 01-02
Vehicle cleaning and protection
C C C
01-02
(1) To be performed by an authorized ski-doo dealer.
(2) Lubricate whenever the vehicle is used in wet conditions (wet snow, rain, puddles).
(3) Before installing new spark plugs at preseason preparation, it is suggested to burn excess storage oil by starting the
engine with the old spark plugs. Only perform this operation in a well-ventilated area.
(4) Emission-related.
(5) Summit models only.
2 mmr2005-110
To Next Page
Loading...
Need help?
General
