Suzuki DF70A - Page 51

Table of Contents 1-iii
Low Pressure Fuel Pump Removal and
Installation.......................................................1G-25
Low Pressure Fuel Pump Inspection ................1G-26
Ignition System........................................ 1H-1
General Description .............................................1H-1
Ignition System Description ................................1H-1
Ignition Control Description .................................1H-2
Component Location ...........................................1H-4
Ignition System Components Location ...............1H-4
Diagnostic Information and Procedures............1H-4
Ignition System Symptom Diagnosis...................1H-4
Ignition System Troubleshooting.........................1H-5
Service Instructions.............................................1H-6
Spark Plug Removal and Installation ..................1H-6
Spark Plug Inspection .........................................1H-6
Ignition Coil Removal and Installation. ................1H-6
Ignition Coil Inspection........................................1H-6
Ignition Coil Operating Signal Inspection ............1H-7
CKP Sensor Inspection.......................................1H-7
CMP Sensor Inspection ......................................1H-7
Ignition Switch Inspection ...................................1H-7
ECM Main Relay Inspection................................1H-7
Starting System .........................................1I-1
General Description .............................................. 1I-1
Electric Starter System Description...................... 1I-1
Starter Motor Operation Condition
Description ......................................................... 1I-2
Start-In-Gear Protection System Description....... 1I-2
Component Location ............................................ 1I-3
Starting System Components Location................ 1I-3
Diagnostic Information and Procedures............. 1I-3
Starter System Troubleshooting........................... 1I-3
Service Instructions.............................................. 1I-4
Starter Motor Removal and Installation................ 1I-4
Starter Motor Test ................................................ 1I-5
Starter Motor Components................................... 1I-6
Starter Motor Disassembly and Assembly ........... 1I-7
Starter Motor Components Inspection and
Servicing ............................................................ 1I-9
Ignition Switch Inspection................................... 1I-13
Starter Motor Relay Inspection........................... 1I-13
Neutral Switch Inspection................................... 1I-14
Emergency Stop Switch Inspection.................... 1I-15
Charging System ..................................... 1K-1
General Description .............................................1K-1
Charging System Description..............................1K-1
Battery Requirement Description ........................1K-2
Component Location ...........................................1K-3
Charging System Components Location.............1K-3
Diagnostic Information and Procedures............1K-3
Charging System Diagnosis................................1K-3
Service Instructions.............................................1K-4
Charging System Construction ...........................1K-4
Flywheel Removal and Installation......................1K-5
Battery Charge Coil Removal and Installation ....1K-6
Battery Charge Coil Inspection ...........................1K-7
Rectifier/Regulator Removal and Installation ......1K-7
Rectifier/Regulator Inspection .............................1K-8
Main Fuse Inspection ..........................................1K-8
http://SelfFixer.com