3
Safety
Operating instructions HERMA 400
22/154 3.28 US (130519)
3.6 Personnel
If persons that were not properly instructed for using the applicator
various risks may occur. The machine shall only be operated, maintained
and serviced by trained personnel. Additional training must be provided.
Otherwise this could lead to serious injuries.
Trained persons have read and understood these operating instructions and have access to these
instructions at any time. Trained persons should have have been instructed for working at the
applicator by HERMA GmbH, or by a HERMA partner.
> Allow only trained persons to install, use, service and work on the label applicator.
> Clearly specify the responsibilities of the personnel for operation, preparation, maintenance and
repair.
> Clearly define the responsibilities of the machine operator. The machine operator must be
empowered to refuse any instructions by a third party if such instructions adversely affect safety.
> Allow only a qualified electrician to service the electric components of the label applicator. He or she
must supervise any auxiliary staff.
Specialist personnel
... are personnel who, based on their specialist training, knowledge and experience and their
knowledge of the applicable provisions, are capable of performing the work assigned to them and
independently recognizing possible dangers.
Trained electrician
... is a person who, based on his or her specialist training, knowledge and experience and knowledge of
the applicable standards and provisions, is capable of performing work on electrical systems and
independently recognizing possible dangers. The trained electrician has received special training for
the working environment in which he or she is active and knows the relevant standards and provisions.
Authorized person
Only persons who can be expected to perform their work reliably are authorized to work as personnel.
Persons whose ability to respond is impacted by, for example, drugs, alcohol or medication are not
authorized.
Unauthorized persons are not permitted to enter the work area! Unauthorized
persons can cause dangerous situations.
The age-specific and job-specific provisions that apply at the operation location must be observed
when selecting personnel.
To Next Page
Loading...
