37A-1
STEERING
CONTENTS
GENERAL INFORMATION 2. . . . . . . . . . . . . . . . . .
SERVICE SPECIFICATIONS 4. . . . . . . . . . . . . . . . .
LUBRICANTS 4. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SEALANT AND ADHESIVE 4. . . . . . . . . . . . . . . . .
SPECIAL TOOLS 5. . . . . . . . . . . . . . . . . . . . . . . . . . .
ON-VEHICLE SERVICE 7. . . . . . . . . . . . . . . . . . . . .
Steering Wheel Free Play Check 7. . . . . . . . . . . . . . .
Steering Angle Check 7. . . . . . . . . . . . . . . . . . . . . . . . .
Tie Rod End Ball Joint Starting Torque
Check 7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Stationary Steering Effort Check 8. . . . . . . . . . . . . . .
Steering Wheel Returnability Check 8. . . . . . . . . . . .
Oil Pump Belt Tension Check 8. . . . . . . . . . . . . . . . . .
Power Steering Fluid Level Check 9. . . . . . . . . . . . .
Power Steering Fluid Replacement 9. . . . . . . . . . . . .
Power Steering System Bleeding 9. . . . . . . . . . . . . . .
Oil Pressure Test 10. . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Steering Oil Pressure Switch Check 11. . . .
Ball Joint Dust Cover Check 11. . . . . . . . . . . . . . . . . .
STEERING WHEEL AND SHAFT* 12. . . . . . . . . .
POWER STEERING GEAR BOX AND
LINKAGE 15. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
POWER STEERING OIL PUMP 29. . . . . . . . . . . .
POWER STEERING OIL HOSES 32. . . . . . . . . . .
WARNINGS REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICLES
WARNING!
(1) Improper service or maintenance of any component of the SRS, or any SRS-related component, can lead to personal
injury or death to service personnel (from inadvertent firing of the air bag) or to the driver and passenger (from
rendering the SRS inoperative).
(2) Service or maintenance of any SRS component or SRS-related component must be performed only at an authorized
MITSUBISHI dealer.
(3) MITSUBISHI dealer personnel must thoroughly review this manual, and especially its GROUP 52B ± Supplemental
Restraint System (SRS) before beginning any service or maintenance of any component of the SRS or any SRS-related
component.
NOTE
The SRS includes the following components: SRS-ECU, SRS warning lamp, air bag module, clock spring and interconnecting
wiring. Other SRS-related components (that may have to be removed/installed in connection with SRS service or maintenance)
are indicated in the table of contents by an asterisk (*).
To Next Page
Loading...
