Section01 MAINTENANCE
Subsection 01 (MAINTENANCE SCHEDULE)
MAINTENANCE SCHEDULE
The maintenance schedule should be adjusted according to operating conditions and use.
NOTE: The schedule provides an equivalence between number of hours and months/year. Maintenance
operations should be carried out following whichever time frame comes due first.
IMPORTANT: Watercraft rental operations or intensive use of watercraft, will require greater frequency
of inspection and maintenance.
When maintenance is completed, the maintenance reminders must be cleared using B.U.D.S. Refer to
the
GAUGE
subsection.
FIRST 10 HOURS
25HOURSOR3MONTHS
50 HOURS or 6 MONTHS
100 HOURS or 1 YEAR
200HOURSor2YEAR
A: Adjust
C: Clean
I: Inspect
L: Lubricate
R: Replace
O: Operator
D: Dealer
TO BE PERFORMED BY
PART/TASK NOTE
ENGINE
Engine oil
(1)
and filter R R D
Rubber mounts I I D
Corrosion protection L O
Supercharger clutch R
(2)
D
(1) Check level before each ride.
(2) See NOTE 1 after maintenance
schedule.
EXHAUST SYSTEM
Exhaust system I
I,
C
(3)
D/O
(3) Daily flushing in salt water or foul
water use.
COOLING SYSTEM
Hose and fasteners I D
Coolant
(1)
IRD
(1) Check level before each ride.
FUEL SYSTEM
Fuel cap, filler neck, fuel tank, fuel tank straps, fuel lines and
connections
II
(4)
D
Fuel system leak test I I D
Throttle body I I D
(4) At storage period or after
100 hours of use whichever comes
first.
AIR INTAKE SYSTEM
Air intake silencer I
I,
C
D
Blow-by valve hose
I,
C
D
—
ELECTRONIC MANAGEMENT SYSTEMS
EMS sensors I I D
Fault codes (ECM, iBR, iS, Cluster) I I D
—
smr2009-011 1
To Next Page
Loading...
Need help?
General