Quick Reference
14-2 CUSA Excel Ultrasonic Surgical Aspirator System User’s Guide
Quick Reference
The following chart lists routine maintenance tasks, when you perform
each task, and the equipment on which you perform them.
Table 14-1.
Routine maintenance tasks
When Equipment Task
Daily or when used CUSA EXcel
console
Disinfect and wipe dry.
Daily or when used Cooling water
reservoir
Discard water from the reservoir.
Daily or when used Footswitch 1. Discard the footswitch cover.
2. Clean the footswitch.
Every 3 months, or every 12
to 15 procedures, whichever
comes first
CUSA EXcel
console
Fill the cooling water reservoir with a solution
consisting of 100 cc of 70% alcohol and 900
cc of water. Connect the handpiece, then turn
on the system. Allow the system to run a few
cooling cycles to clean the interior tubing.
Turn off the system. Discard the alcohol
solution, then fill the reservoir with distilled
water. Turn on the system, and allow it to
cycle the water to remove the alcohol solution
from the tubing.
Every 6 months, or when
needed
CUSA EXcel
console
Replace the contamination guard. Write either
the installation date or the expiration date on
the guard.
Once a year CUSA EXcel
console
Contact a Integra service representative to
replace the cooling water pump tubing.
Every month or 80 hours
of use
Handpiece Apply a high viscosity lubricant to the
handpiece connector o-rings.
Every 6 months or 500 hours
of use
Handpiece Replace the handpiece connector o-rings.
To Next Page
Loading...
Need help?
General
