G-30
MX5100, WSM
G GENERAL
Checking Radiator Hose and Hose Clamp
Check to see if radiator hoses are properly fixed every 200 hours
of operation or six months, whichever comes first.
1. If hose clamps are loose or water leaks, tighten bands securely.
2. Replace hoses and tighten hose clamps securely, if radiator
hoses are swollen, hardened or cracked.
Replace hoses and hose clamps every 2 years or earlier if
checked and found that hoses are swollen, hardened or cracked.
■ Precaution at Overheating
Take the following actions in the event the coolant temperature
be nearly or more than the boiling point, what is called
“Overheating”.
1. Park the tractor in a safe place and keep the engine unloaded
idling.
2. Do not stop the engine suddenly, but stop it after about 5 minutes
of unloaded idling.
3. Keep yourself well away from the machine for further 10 minutes
or while the steam blows out.
4. Check that there are no dangers such as burns, get rid of the
causes of overheating according to the manual, see
“Troubleshooting” section, and then, start again the engine.
W10347370
Checking Power Steering Oil Line
1. Check to see that all lines and hose clamps are tight and not
damage.
2. If hoses and clamps are found worn or damaged, replace or
repair them at once.
W10346350
Checking Intake Air Line
1. Check to see that hoses and hose clamps are tight and not
damaged.
2. If hoses and clamps are found worn or damaged, replace or
repair them at once.
W10345660
(1) Radiator Hose (2) Clamp
(1) Power Steering Pressure Hoses
(1) Hose (2) Hose Clamp
To Next Page
Loading...
