Toyota 2002 Camry - Engine Mechanical Torque Specification

030EU–01
03–18
–SERVICE SPECIFICATIONS ENGINE MECHANICAL
129Author: Date:
2002 CAMRY REPAIR MANUAL (RM881U)
TORQUE SPECIFICATION
2AZ–FE
Part Tightened N⋅m kgf⋅cm ft⋅lbf
Engine mounting bracket No.2 RH x Timing chain cover 52 531 38
Engine moving control rod w/ bracket x Engine mounting bracket No.2 RH 64 653 47
Engine moving control rod w/ bracket x Fender apron RH 64 653 47
Engine mounting stay No.2 RH x Cylinder head 64 653 47
Engine mounting stay No.2 RH x Engine mounting bracket No.2 RH 64 653 47
Front wheel RH 103 1,050 76
Drain plug (Automatic transaxle) 49 500 36
Drain plug (Manual transaxle) 49 500 36
Engine hanger No.1 x Cylinder head 38 387 28
Engine hanger No.2 x Cylinder head 38 387 28
E.F.I. Engine coolant temperature sensor x Cylinder head 20 208 15
Knock control sensor x Cylinder block 39 398 29
Engine oil pressure switch assy x Cylinder head 15 153 11
Water by–pass pipe No.1 x Cylinder block 9.0 92 80 in.⋅lbf
Transverse engine engine mounting bracket x Cylinder block 54 551 40
Drive shaft bearing bracket x Cylinder block 64 653 47
V–ribbed belt tensioner assy x Timing chain cover 59.5 607 44
Ignition coil assy x Cylinder head 9.0 92 80 in.⋅lbf
Water inlet x Cylinder block 9.0 92 80 in.⋅lbf
Exhaust manifold converter x Cylinder head 37 378 27
Exhaust manifold stay x Exhaust manifold converter 44 449 32
Manifold converter insulator No. 1 x Exhaust manifold converter 12 122 9
Oil level gauge guide x Water by–pass pipe No. 1 9.0 92 80 in.⋅lbf
Intake manifold x Cylinder head 30 306 22
Drive plate & ring gear (Automatic transaxle) x Crankshaft 98 1,000 72
Flywheel sub–assy (Manual transaxle) x Crankshaft 130 1,330 96
Starter assy x Automatic transaxle assy 39 398 29
Starter assy x Manual transaxle assy 39 398 29
Engine mounting insulator LH x Automatic transaxle assy 95 969 70
Engine mounting insulator LH x Manual transaxle assy 143 1,459 106
Engine mounting insulator RH x Transverse engine engine mounting bracket 95 969 70
Engine mounting insulator FR x Engine mounting bracket FR 87 888 64
Engine mounting bracket rear No. 2 x Engine lateral control rod(Manual
transaxle)
89 910 69
Vane pump assy x Timing chain cover 43 439 31
Frame side plate x Front frame assy Bolt A 85 867 63
Frame side plate x Body Bolt B 32 326 24
Front suspension member brace rear x Front frame assy Bolt C 85 867 63
Front suspension member brace rear x Body Bolt D 32 326 24
Steering intermediate shaft 35 357 26
Drive plate & ring gear x Torque converter 41 418 30
Front suspension arm sub–assy lower No. 1 x Lower ball joint 127 1,296 94
Tie rod assy x Steering knuckle 49 500 36
Speed sensor front LH (w/ ABS) x Steering knuckle 8.0 82 71 in.⋅lbf
Speed sensor front RH (w/ ABS) x Steering knuckle 8.0 82 71 in.⋅lbf
Front axle hub LH nut x Front drive shaft 294 3,000 217
Front stabilizer link assy x Front suspension 74 755 55
Air cleaner assy x Body 5.0 51 44 in.⋅lbf