Dieci SAMSON AGRI MAX - Page 219

Maintenance | 12
DOCMA0000006‐UK ﴾ENG﴿ ‐ Samson FPT 3A 219
– Ifinspectionormaintenanceiscarriedoutonvehiclesorequipmentwhicharestillcoveredwithmud,oil,
etc., operators risk sliding or falling and the visual analysis of components is made more difficult.
Thoroughlycleanthevehicleorequipmentbeforeeveryoperation.
– Makesureaboutthemaintenanceproceduresbeforestartingthework.
– Keeptheworkareacleananddry.
– Replacewornorfaultycomponents.
– Eliminateaccumulationsofgreaseoilanddebris.
– Theknurledplates(bulbplates)andthecabflooraretheonlypartsofthevehiclethatcanbesteppedon.
Usealadder(suitablefortheintendedpurpose)formaintenanceofpartsthatcannotbereachedfrom
theground.
DANGER
Do not carry out any maintenance operation with running engine or moving vehicle.
Should maintenance need to be performed with the engine running, ask at least two workers for help and
observe the following instructions:
– Oneworkermustalwaysbeseatedinthedriver'sseat,readytoswitchofftheengineatanytime.
– Allworkersmustremainincontactwithoneanother.
– Takecarenottoremainentrappedincomponentsduringtheexecutionofoperationsperformedonthe
fan,fanbeltorotherrotatingparts.
– Donottouchleversorcontrolpedals.Shouldaleverorpedalneedtobemoved,alwayswarnoperators
firstsotheycanmoveoutofthedangerousarea.
– Doallowinstrumentsorotherobjectstofallintothevehiclerotatingparts,asthesepartsmaybreakand
beprojectedout.
– Thevehiclemustbeoutdoorswhentheengineisrunning.Thevehiclecanbekeptinaclosedareaonlyif
itisproperlyventilatedandthevehicleisequippedwithspecificpurifiers.
WARNING
If you need to work under raised mobile parts (booms, shovels, etc.) block them using
spacers placed on cylinder rods or lean them up against appropriately sized supports.
If you need to perform repair or maintenance work under the vehicle, firmly support the equipment
being used and the vehicle with blocks that are solid enough to support the weight.
– Store attachments removed from the vehicle in a safe place where they do not risk falling. Take
precautionstopreventunauthorizedpersonsfromapproachingthestoragearea.
DANGER
Do not rest metal parts on the battery.
– Weldingoperationsmustalwaysbecarriedoutbyqualifiedweldersandinareasequippedwithsuitable
equipment.Thereis dangerofgasleaks, fireorelectrocutionduring weldingoperations.Do not allow
unqualifiedpersonneltocarryoutsuchoperations.
– Disconnectthebatterywiresbeforeworkingontheelectricalsystemorbeforecarryingoutarcwelding
onthevehicle.