Dieci SAMSON AGRI MAX - Left Side Components Description

To Next Page

To Previous Page

6 | Vehicle description

58 DOCMA0000006‐UK ﴾ENG﴿ ‐ Samson FPT 3A

6.1 Left side components description

Illustration1: 1506431:Leftsideview

1 Cab 2 Stepsforclimbingon

3 Telescopicboom 4 Boomhead

5 Attachmentholdingplate 6 Wheel

7 Epicycloidalreductiongear 8 Frontaxle

9 Rearaxle 10 Leftfrontheadlight

11 Leftrearheadlight 12 Fueltank

13 Oiltank

Main Page

Default Chapter4
- General4
- Identification of the Vehicle5
2 Letter7
- Table of Contents8
3 Introduction16
- Manual Structure16
- Purpose and Content16
- Preservation16
- Recipients16
- Terms, Units of Measurement and Abbreviations Used18
- Symbols Used20
  - Symbols Key in Manual20
- Machine General Warnings20
- Equipment General Warnings21
- Intended Use22
- Contraindications for Use22
- Declaration of First Test22
- Liability22
- Manufacturer23
- Certification and CE Marking24
4 Warranty25
- Exclusions from the Guarantee25
- Warranty: Duration25
- Warranty: Commencement25
- Warranty: Activation25
- Warranty: Validity26
- Warranty: Intervention Request26
  - Guarantee: Claim26
  - Obligation of Vehicle Downtime27
- Non-Activation, Failure to Grant, Termination27
  - Warranty: Failure to Grant27
  - Guarantee: Termination27
- Final Terms27
5 Safety Regulations28
- General Warnings28
- Safety Indications30
- Personal Protective Equipment30
- Preparing for Accidents32
- Preventing Fires and Accidents33
- Storing Dangerous Liquids37
- Warnings for Safe Working38
- Working in Windy Conditions45
- Assessing the Consistency of the Work Ground46
- Moving Safely46
- General Warnings for Moving the Load47
- Use of Cables, Ropes and Slings49
- Road Travel50
  - Road Travel Warnings50
  - Road Travel Instructions50
- Momentary Stop51
- Parking the Vehicle51
- Starting and Stopping the Machine53
6 Vehicle Description57
- Left Side Components Description58
- Destroy Side Components Description59
- Engine Components Description60
- Cab Components Description61
7 Safety Devices62
- Safety Stickers62
- Reference to Safety Devices67
8 Components Description69
- ROPS - FOPS Cab69
  - Door Opening70
  - Climbing In/Out70
  - Door Electric Glass71
  - Rear Glass72
  - Canopy72
  - Sunshade73
  - Cab Ventilation73
  - Air Conditioning75
  - Socket76
  - Storage Compartment76
  - Cab Lighting76
  - Steering Wheel77
  - Multifunction Lever77
  - Lights Turning on79
  - Emergency Lights82
  - Seat83
  - Emergency Stop87
  - Spirit Level88
  - Emergency Exit: Rear Glass89
  - Emergency Exit: Front Glass89
  - Cab Front Glass Protection90
  - Warnings in Case of Vehicle Tipping90
- TFT Instrument Panel91
  - Components91
  - General Alarm Warning Light92
  - Initial Check93
  - Home93
  - Clock and Clock Setting94
  - Hour Meter94
  - Boom Chains Error Icon95
  - Levelness Icon95
  - Steering Mode Icon95
  - Speed Limiter Icon96
  - Menu97
  - Info98
  - Active Errors98
  - Service99
  - Anti-Tipping Device100
- Parking Brake107
  - Pressure Gauge109
  - Braking Circuit Errors List109
  - Deactivating the External Parking Brake Manually110
- Electrical Steering Selector111
- Wheels Alignment112
- Joystick114
  - Joystick with Capacitive Deadman Sensor114
  - Joystick with Capacitive Deadman Switch with FNR Function115
  - Joystick with Mechanical Deadman Button118
  - Joystick for man Basket Prearrangement122
  - Joystick Error List123
- Continuous Oil Function126
  - Continuous Oil Function on Joystick with Capacitive Deadman126
  - Continuous Oil Function on Joystick with Mechanical Deadman127
  - Continuous Oil Function for Vehicles with man Basket Function127
- Rear Hydraulic Sockets128
- Hydraulic Sockets and Electrical Contact on Boom Head129
- Electrical Contact on Boom Head131
- Equipment Quick Coupling132
  - Quick Coupling with Single Lock on Closed Circuit Machine132
  - Quick Coupling with Single Lock on Open Circuit Machine133
  - Quick Coupling with Double Cylinder134
- Plate Translation Unit135
- Transmission136
  - Movement Selection Lever136
  - Manual Gear Shift Selection137
  - Service Braking Pedal138
  - Inching Pedal138
  - Accelerator Pedal139
  - Manually Disable off the 2-Gear Hydrostatic Transmission140
- Electronic Hand Throttle140
- Safety Rod141
- Wheel Wedge142
- Block Valves142
- Diagrams Notebook142
  - Capacity Diagrams142
- Water Heater149
- Fan Reversal150
- Boom Suspension150
- Remote Control151
  - Remote Control: Description152
  - LCD Display153
  - Boom Extension / Retraction Lever155
  - Services Lever155
  - Turret Rotation Lever (for Rotary Vehicles)155
  - Remote Control: Use156
  - Boom Head Solenoid Valve Lever156
  - Remote Control: Turn off the Vehicle and the Remote Control157
  - Remote Control: Receiver157
  - Remote Control: Recharge157
  - Remote Control: Additional Information157
- Transverse Leveling158
- Engine FPT Series NEF4 Stage IIIA /Tier 3159
9 Agriculture Components Description160
- Agricultural Applications160
- Forest and Forestry Applications160
- Caisson Descent161
- Trailer Descent162
- Hydraulic Power Take off (PTO)163
- Trailer Towing166
- Trailers Braking169
- Rear Trailer Hitch173
- Height Adjustable Tow Hitch Adjustment174
- Pick-Up Hitch174
10 Equipment176
- General Warnings on Equipment Use176
  - Equipment Pre-Use Checks178
- Equipment Installation Procedure180
  - Safety Pin Outline182
- Hydraulic Connections183
- Electrical Connections189
  - Warnings for Electrical Connections189
  - Procedure for Connecting Electrical Connections189
- Equipment Removal191
- Forks194
- Fork Spreader205
- Bucket209
- Equipment Lifting213
- Equipment Transport213
11 Emergency Procedure214
- Vehicle Towing214
  - Machine Towing with Electrical Panel on215
  - Towing the Machine with Engine in Failure215
12 Maintenance217
- Maintenance Warnings217
  - Avoid Accidents During Maintenance218
- Engine Hood Opening221
- Engine Lower Protection Plate Removal222
- Battery223
  - Low Maintenance Batteries224
  - Zero" Maintenance Batteries224
  - Battery: Instructions for Recharging224
  - Battery Cut-Off Switch225
  - Battery: Replacement225
  - Start up with Auxiliary Batteries226
- Fuel227
  - Specifications for Recommended Fuel227
  - Cleaning and Storing Fuel228
  - Refueling228
  - Fuel Tank: Cleaning228
- Safety Stickers: Inspection228
- Lubrication229
- Preliminary Maintenance Operations230
  - Prepare the Vehicle for Maintenance230
- Engine Maintenance231
  - Belts: Check and Adjustment231
  - Engine Oil: Check and Filling up231
- Air Filter: Cleaning and Replacement231
- Radiator Maintenance233
  - Air Recirculation Grids and Nets233
  - Radiator: Checking and Cleaning233
  - Radiator: Liquid Filling up and Replacement234
- Hydraulic System Maintenance235
  - Hydraulic Oil: Check and Replacement235
  - Hydraulic Oil Intake Filter: Replacement236
  - Return Hydraulic Oil Filter237
- 2 Speed Transmission Maintenance237
  - Oil Change: Inspection237
  - Oil Change: Check and Replacement237
- Brakes Maintenance238
  - Brake: Inspection238
  - Brakes Oil: Check and Replacement238
- Wheel Maintenance239
  - Epicycloidal Reduction Gear Oil: Check and Replacement239
  - Wheel Nuts Tightening239
  - Tires240
- Lighting242
  - Headlight243
  - Tail Light244
  - Work Light244
  - Led Work Light245
- Window Washer Fluid Tank245
- Ventilation System Maintenance246
  - Cab Ventilation Filter: Cleaning and Replacement246
  - Air Conditioning: Cleaning247
- Boom Maintenance248
  - Sliding Blocks Maintenance248
  - Boom Lubrication with Grease248
- Cylinder Lock Valves Maintenance250
- Differential Axles Maintenance252
  - Differential Axles Oil: Check and Replacement252
- Hydraulic Fittings Tightening Torques253
- Bolts Tightening Torques254
  - Bolts Tightening Torques: Fine Pitch254
  - Bolts Tightening Torques: Coarse Pitch256
13 Technical Assistance Service258
- Spare Parts Supply258
- Assistance to Owner / Operator258
- Technical Assistance Service Address258
14 Problems Diagnostics259
- Engine259
- Hydraulic Transmission System259
- Brakes260
- Steering Wheel260
- Telescopic Boom260
15 Errors List262
- Reference to Errors Lists262
- Basket Pre-Arrangement Errors List262
16 Cleaning265
- Machine Cleaning265
- Glasses Cleaning265
- Cleaning the Cab265
- Safety Stickers Cleaning266
17 Lifting the Vehicle267
18 Transporting the Vehicle on a Trailer268
19 Storing the Vehicle269
- Long Period of Inactivity269
- Restarting the Vehicle269
20 Waste Disposal271
- Ecological Considerations271
- Protect the Environment271
21 Demolition272
22 Wiring Diagram273
- Components Legend273
- Wiring Diagram Sheets278
- Fuse Box291
- Engine Compartment Fuses292
23 Hydraulic Diagram293
- Components Legend293
- Standard Hydraulic Diagram294
24 Technical Data296
- Samson 75.10296
  - Equipment300
- Agri Max 75.10302
  - Equipment305
- Environmental Conditions308
- Electromagnetic Interference308
- Radiations308
- Standard Hydraulic Oil309
- Hydraulic Oil for Cold Climates309
- Fork Technical Data311
- Fork Spreader Technical Data312
- Buckets Technical Data313
- Tires Data314
25 Control and Maintenance Logs315
- Type of Logs315
  - Control Log315
  - Maintenance Log315
- Instructions for Compiling the Logs315
- Periodic Checks and Recording Mode (Italian Only)317
- Obligation and How to Report to I.N.A.I.L. (National Institute for Insurance against Accidents at Work) (Italy Only)317
- Control Log318
- Maintenance Log327

Dieci SAMSON AGRI MAX - Left Side Components Description

Table of Contents