Suzuki RM-Z250 Owner's Service Manual

14
ELECTRICAL SYSTEM 14-1
CONTENTS
ELECTRICAL SYSTEM
CAUTIONS IN SERVICING ....................................................................... 14- 2
CONNECTOR ...................................................................................... 14- 2
COUPLER ........................................................................................... 14- 2
SEMI-CONDUCTOR EQUIPPED PART ............................................. 14- 2
USING THE MULTI-CIRCUIT TESTER .............................................. 14- 2
SWITCH ............................................................................................... 14- 2
LOCATION OF ELECTRICAL COMPONENTS ........................................ 14- 3
CONSTRUCTION ...................................................................................... 14- 4
ELECTRICAL SYSTEM ...................................................................... 14- 4
ELECTRICAL CIRCUIT ....................................................................... 14- 4
TROUBLESHOOTING ........................................................................ 14- 5
IGNITION SYSTEM .................................................................................... 14- 7
IGNITION SYSTEM PEAK VOLTAGE INSPECTION ......................... 14- 7
IGNITION SYSTEM COIL INSPECTION ............................................. 14- 8
IGNITION COIL PRIMARY PEAK VOLTAGE INSPECTION .................... 14- 9
IGNITION COIL/PLUG CAP INSPECTION ......................................... 14-10
ENGINE STOP SWITCH INSPECTION .............................................. 14-11
MAGNETO ROTOR ................................................................................... 14-12
REMOVAL ........................................................................................... 14-12
INSTALLATION ................................................................................... 14-13
STATOR ..................................................................................................... 14-14
REMOVAL ........................................................................................... 14-14
INSTALLATION ................................................................................... 14-14

Suzuki RM-Z250 Specifications

General

Displacement	249cc
Fuel System	Fuel injection
Bore x Stroke	77.0 mm x 53.6 mm
Ignition	Electronic (CDI)
Transmission	5-speed constant mesh
Final Drive	Chain
Front Suspension	Inverted telescopic, coil spring, oil damped
Rear Suspension	coil spring, oil damped
Front Brakes	Single disc
Rear Brakes	Single disc
Front Tires	80/100-21
Rear Tires	100/90-19
Overall Width	830 mm
Ground Clearance	345 mm (13.6 in)
Seat Height	955 mm