Home
Fujitsu
Server
SPARC Enterprise M5000
Fujitsu SPARC Enterprise M5000 User Manual
5
of 1
of 1 rating
310 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
D-2
SPARC Enterprise M4000/M5000 Servers Service Manual
•
December 2010
D.1
Serial
Port
T
ABLE
D-1
Serial
Port
Setting
Pin
No
Signal
Name
Input/Output
Description
1
R
TS
Output
Request
to
Send
2
DTR
Output
Data
T
erminal
Ready
3
TXD
Output
Send
Data
4
GND
---
Ground
5
GND
---
Ground
6
RXD
Input
Receive
Data
7
DSR
Input
Data
Set
Ready
8
CTS
Input
Clear
to
Send
12
4
6
8
357
279
281
Table of Contents
Default Chapter
1
Default Chapter
1
Service Manual
1
Table of Contents
5
Preface
17
Text Conventions
19
Notes on Safety
20
Documentation Feedback
20
1 Safety and Tools
21
Safety Precautions
21
System Precautions
22
Electrical Safety Precautions
22
Equipment Rack Safety Precautions
22
Filler Boards and Filler Panels
23
Handling Components
23
2 Fault Isolation
25
Determining Which Diagnostics Tools to Use
25
Checking the Server and System Configuration
28
Checking the Hardware Configuration and FRU Status
28
Checking the Hardware Configuration
29
Checking the Software and Firmware Configuration
30
Checking the Firmware Configuration
31
Checking the Software Configuration
31
Downloading the Error Log Information
32
Operator Panel
32
Error Conditions
38
Predictive Self-Healing Tools
38
Monitoring Output
41
Messaging Output
41
LED Functions
42
Using the Diagnostic Commands
45
Using the Showlogs Command
45
Using the Fmdump Command
46
Fmdump -V Command
46
Fmdump -E Command
47
Using the Fmadm Faulty Command
47
Fmadm Repair Command
47
Fmadm Config Command
48
Using the Fmstat Command
48
Traditional Oracle Solaris Diagnostic Commands
49
Using the Iostat Command
50
Options
51
Using the Prtdiag Command
51
Options
54
Using the Prtconf Command
54
Using the Netstat Command
56
Options
57
Using the Ping Command
58
Options
59
Using the Ps Command
59
Options
60
Using the Prstat Command
60
Other Issues
61
Can't Locate Boot Device
61
3 Periodic Maintenance
63
Tape Drive Unit
63
Cleaning the Tape Drive Unit
63
4 FRU Replacement Preparation
65
FRU Replacement Method
65
Active Replacement
68
Removing a FRU from a Domain
68
Removing and Replacing a FRU
69
Adding a FRU into a Domain
69
Verifying Hardware Operation
70
Hot Replacement
70
Removing and Replacing a FRU
71
Verifying Hardware Operation
73
Cold Replacement (Powering the Server off and On)
76
Powering the Server off Using Software
76
Powering the Server on Using Software
77
Powering the Server off Manually
78
Powering the Server on Manually
78
Verifying Hardware Operation
79
5 Internal Components Access
83
Sliding the Server in and out to the Fan Stop
83
Sliding the Server out of the Equipment Rack
84
Sliding the Server into the Equipment Rack
86
Top Cover Remove and Replace
87
Removing the Top Cover
87
Replacing the Top Cover
90
Fan Cover Remove and Replace
90
Removing the Fan Cover
90
Replacing the Fan Cover
92
6 Storage Devices Replacement
93
Hard Disk Drive Replacement
93
Accessing the Hard Disk Drive
96
Removing the Hard Disk Drive
96
Installing the Hard Disk Drive
97
Securing the Server
97
Accessing the Hard Disk Drive Backplane of the M4000 Server
98
Removing the Hard Disk Drive Backplane of the M4000 Server
98
Installing the Hard Disk Drive Backplane of the M4000 Server
99
Securing the Server
100
Accessing the Hard Disk Drive Backplane of the M5000 Server
101
Removing the Hard Disk Drive Backplane of the M5000 Server
102
Installing the Hard Disk Drive Backplane of the M5000 Server
102
Securing the Server
103
CD-RW/DVD-RW Drive Unit (DVDU) Replacement
104
Identifying the Type of CD-RW/DVD-RW Drive Unit
107
Accessing the CD-RW/DVD-RW Drive Unit
108
Removing the CD-RW/DVD-RW Drive Unit
108
Installing the CD-RW/DVD-RW Drive Unit
109
Securing the Server
109
Accessing the CD-RW/DVD-RW Drive Backplane of the M4000 Server
110
Removing the CD-RW/DVD-RW Drive Backplane of the M4000 Server
110
Installing the CD-RW/DVD-RW Drive Backplane of the M4000 Server
111
Securing the Server
111
Accessing the CD-RW/DVD-RW Drive Backplane of the M5000 Server
112
Removing the CD-RW/DVD-RW Drive Backplane of the M5000 Server
113
Installing the CD-RW/DVD-RW Drive Backplane of the M5000 Server
113
Securing the Server
114
Tape Drive Unit Replacement
115
Accessing the Tape Drive Unit
118
Removing the Tape Drive Unit
118
Installing the Tape Drive Unit
119
Securing the Server
119
Accessing the Tape Drive Backplane of the M4000 Server
120
Removing the Tape Drive Backplane of the M4000 Server
121
Installing the Tape Drive Backplane of the M4000 Server
121
Securing the Server
122
Accessing the Tape Drive Backplane of the M5000 Server
123
Removing the Tape Drive Backplane of the M5000 Server
124
Installing the Tape Drive Backplane of the M5000 Server
124
Securing the Server
125
7 Power Systems Replacement
127
Power Supply Unit Replacement
127
Accessing the Power Supply Unit
130
Removing the Power Supply Unit
130
Installing the Power Supply Unit
131
Securing the Server
131
8 I/O Unit Replacement
135
PCI Cassette Replacement
136
Accessing the PCI Cassette
137
Removing the PCI Cassette
137
Installing the PCI Cassette
138
Securing the Server
139
PCI Card Replacement
139
Removing the PCI Card
139
Installing the PCI Card
140
I/O Unit Replacement
142
Accessing the I/O Unit
142
Removing the I/O Unit
142
Installing the I/O Unit
143
Securing the Server
144
I/O Unit DC-DC Converter Replacement
144
Accessing the I/O Unit DC-DC Converter
146
Ddc_B#0)
146
Removing the I/O Unit DC-DC Converter (DDC_A #0 or DDC_B #0)
146
Securing the Server
153
Accessing the I/O Unit DC-DC Converter Riser
153
Removing the I/O Unit DC-DC Converter Riser
154
Replacing the I/O Unit DC-DC Converter Riser
156
Securing the Server
156
9 XSCF Unit Replacement
159
Accessing the XSCF Unit
161
Removing the XSCF Unit
162
Installing the XSCF Unit
163
Securing the Server
163
10 Fan Modules Replacement
165
Fan Module Replacement
165
Accessing the 60-MM Fan Module
168
Removing the 60-MM Fan Module
169
Installing the 60-MM Fan Module
170
Securing the Server
170
Accessing the 172-MM Fan Module
171
Removing the 172-MM Fan Module
172
Installing the 172-MM Fan Module
173
Securing the Server
173
Accessing the 60-MM Fan Backplane
174
Removing the 60-MM Fan Backplane
175
Installing the 60-MM Fan Backplane
176
Securing the Server
176
Accessing the SPARC Enterprise M4000 172-MM Fan Backplane
177
Removing the SPARC Enterprise M4000 172-MM Fan Backplane
177
Installing the M4000 Server 172-MM Fan Backplane
180
Securing the Server
180
Accessing the M5000 Server 172-MM Fan Backplane
181
Removing the M5000 Server 172-MM Fan Backplane
181
Installing the M5000 Server 172-MM Fan Backplane
184
Securing the Server
184
11 Memory Board Replacement
185
Memory Board Replacement
187
Accessing the Memory Board
188
Removing the Memory Board
189
Installing the Memory Board
190
Securing the Server
190
DIMM Replacement
191
Confirmation of DIMM Information
192
Memory Installation Configuration Rules
193
Installing Memory
194
Accessing the Dimms
194
Removing the Dimms
195
Installing the Dimms
196
Securing the Server
196
12 CPU Module Replacement
197
Accessing the CPU Module
200
Removing the CPU Module
201
Installing the CPU Module
202
Securing the Server
202
CPU Upgrade
203
SPARC64 VII/SPARC64 VII+ CPU Modules Added to a New Domain
204
Adding a SPARC64 VII/SPARC64 VII+ CPU Module to a New Domain
204
SPARC64 VII/SPARC64 VII+ Processors Added to an Existing Domain
207
Adding a SPARC64 VII/SPARC64 VII+ CPU Module to a Domain Configured with SPARC64
207
Preparing to Add SPARC64 VII/SPARC64 VII+ Processors to an
207
Upgrading a SPARC64 VI CPU Module to SPARC64 VII/SPARC64 VII+ on an Existing Domain
211
Motherboard Unit Replacement
213
Accessing the M4000 Server Motherboard Unit
216
Removing the M4000 Server Motherboard Unit
217
Installing the M4000 Server Motherboard Unit
218
Securing the Server
218
Accessing the M5000 Server Motherboard Unit
219
Removing the M5000 Server Motherboard Unit
220
Installing the M5000 Server Motherboard Unit
222
Securing the Server
223
DC-DC Converter Replacement
224
Accessing the M4000 Server DC-DC Converter
226
Removing the M4000 Server DC-DC Converter
227
Installing the M4000 Server DC-DC Converter
228
Securing the Server
228
Accessing the M5000 Server DC-DC Converter
229
Installing the M5000 Server DC-DC Converter
230
Removing the M5000 Server DC-DC Converter
230
Securing the Server
230
Motherboard Unit Upgrade
231
Notes on Upgrading
231
Replacing a Motherboard Unit as an Upgrade in an Existing Domain
232
14 Backplane Unit Replacement
237
Accessing the M4000 Server Backplane Unit
237
Removing the M4000 Server Backplane Unit
239
Installing the M4000 Server Backplane Unit
241
Securing the Server
242
Accessing the M5000 Server Backplane Unit
243
Removing the M5000 Server Backplane Unit
244
Installing the M5000 Server Backplane Unit
246
Securing the Server
246
15 Operator Panel Replacement
249
Location Number Component
250
Accessing the Operator Panel
252
Removing the Operator Panel
252
Installing the Operator Panel
255
Securing the Server
255
Components List
257
DC-DC Converter (DDC_A#0)
261
DC-DC Converter (DDC_A#1)
261
DC-DC Converter (DDC_A#2)
261
DC-DC Converter (DDC_A#3)
261
DC-DC Converter (DDC_B#0) (with Metal Heatsink)
261
DC-DC Converter (DDC_B#1) (with Metal Heatsink)
261
Rules for System Configuration
263
Server Configuration
263
B.1 Server Configuration
263
FRU List
267
Server Overview
267
C.1 Server Overview
267
System Boards
269
C.2 System Boards
269
C.2.1 Motherboard Unit
269
Motherboard Unit
269
C.2.2 CPU Module
270
CPU Module
270
Memory Board
271
Backplane Unit
272
I/O Unit
272
C.3 Backplane Unit
272
C.4 I/O Unit
272
Power
273
C.5 Power
273
FAN Module
274
C.6 FAN Module
274
Extended System Control Facility Unit
275
Drives
276
C.8 Drives
276
C.8.1 Hard Disk Drive
276
Hard Disk Drive
276
CD-RW/DVD-RW Drive Unit (DVDU
277
Tape Drive Unit (TAPEU
277
External Interface Specifications
279
Serial Port
280
D.1 Serial Port
280
UPC (UPS Control) Port
281
USB Port
281
D.3 USB Port
281
Connection Diagram for Serial Cable
282
E.1 Overview
283
UPS Controller
283
Overview
283
E.2 Signal Cables
283
Signal Cables
283
Signal Line Configuration
284
Input Circuit
285
E.4 Power Supply Conditions
285
E.4.1 Input Circuit
285
Output Circuit
286
UPS Cable
286
E.4.2 Output Circuit
286
E.5 UPS Cable
286
UPC Connector
287
E.6 UPC Connector
287
Air Filters
289
M4000 and M5000 Servers Air Filter
290
Command Operations Procedures
290
Air Filter Installation for the M4000 Server
291
Removing the Air Filter from the M4000 Server
296
Air Filter Installation for the M5000 Server
297
F.3.1 Removing the Air Filter from the M5000 Server
301
F.3.2 Servicing the Air Filter
302
Index
309
Other manuals for Fujitsu SPARC Enterprise M5000
Overview Guide
76 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Fujitsu SPARC Enterprise M5000 and is the answer not in the manual?
Ask a question
Fujitsu SPARC Enterprise M5000 Specifications
General
Brand
Fujitsu
Model
SPARC Enterprise M5000
Category
Server
Language
English
Related product manuals
Fujitsu SPARC Enterprise M3000
56 pages
Fujitsu SPARC EnterpriseM3000
450 pages
Fujitsu Oracle SPARC M12-2
560 pages
Fujitsu FUTRO S720
71 pages
Fujitsu FUTRO S920
71 pages
Fujitsu ServerView
12 pages
Fujitsu FUTRO S930
71 pages
Fujitsu PRIMERGY S60
99 pages
Fujitsu ETERNUS CS800 S5
634 pages
Fujitsu PRIMERGY TX150 S3
95 pages
Fujitsu PRIMERGY RX300 S7
90 pages
Fujitsu PRIMERGY TX200 S6
126 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General