Geely FC - Page 231

To Next Page

To Previous Page

Air conditioner--Refrigerant

Reading of filling meter (referred value)

 220 

Pressure of low pressure side

Fan “HI” phase

Blower “LO” phase

Pressure of high

pressure side

Main Page

Default Chapter6
- Table of Contents6
Brief Introduction on Geely Model “FC”12
- Brief Introduction on Geely Model "FC" Basic Parameters12
Maintenance Period Regular Maintenance Items15
Engine Control System EFI System19
- On-Vehicle Inspection19
- Inspection20
- Throttle Body Assembly24
  - Removing, Installing and Disassembling, Assembling24
Fuel25
- Fuel System25
- Injection Nozzle Assembly29
  - Replacement29
- Fuel Pump Assembly31
  - Removing, Installing and Disassembling, Assembling31
- Fuel Tank Assembly32
  - Removing, Installing and Disassembling, Assembling32
Exhaust Gas Control34
- Exhaust Gas Control System34
  - On-Vehicle Inspection34
  - Inspection36
Engine Mechanism Engine Assembly37
- Inspection37
- Drive Belt40
  - Replacement40
- Valve Clearance41
  - Adjustment41
- Engine Assembly47
  - Replacement47
- Timing Chain Assembly56
  - Replacement56
- Camshaft63
  - Replacement63
- Crankshaft Front Oil Seal Assembly71
  - Replacement71
- Crankshaft Rear Oil Seal Assembly73
  - Replacement73
- Cylinder Cover Gasket Components74
  - Replacement74
Exhaust76
- Exhaust Pipe Assembly76
  - Removing, Installing and Disassembling, Assembling76
Cooling Cooling System77
- On-Vehicle Inspection77
- Inspection77
- Cooling Fan System79
  - On-Vehicle Inspection79
  - Inspection79
- Water Pump Assembly80
  - Replacement80
- Temperature Regulator Components82
  - Replacement82
- Radiator with Electronic Fan Assembly83
  - Replacement83
- Coolant84
  - Replacement84
Lubrication Lubricating System85
- On-Vehicle Inspection85
- Oil Filter Assembly86
  - Replacement86
- Oil Pump Assembly87
  - Replacement87
Ignition Ignition System88
- Inspection88
- On-Vehicle Inspection88
Starting and Charging Starting System90
- Inspection90
- Charging System92
  - Precautions92
  - On-Vehicle Inspection93
- Alternator Components95
  - Replacement95
  - Starter Components96
    - Replacement96
Front Suspension97
- Front Suspension System97
- Front Wheel Alignment98
  - Adjustment98
- Front Absorber and Helical Spring101
  - Overhaul101
  - Handling104
- Lower Left Control Arm Assembly105
  - Replacement105
- Front Stabilizer Bar107
  - Overhaul107
- Front Left Lower Control Arm Ball Joint Assembly110
  - Replacement110
Rear Suspension111
- Rear Suspension System111
- Rear Wheel Alignment112
  - Adjustment112
- Rear Strut Assembly113
  - Overhaul113
  - Handling115
- Rear Stabilizer Bar116
  - Overhaul116
- Rear Shaft Assembly117
  - Overhaul117
Tire and Wheel120
- Wheel and Tire System120
  - Inspection120
Drive Shaft Drive Shaft122
- Notes122
- Malfunction Phenomenon Table122
- Inspection on Automobile123
- Front Drive Shaft124
  - Overhaul124
- Left Front Shaft Hub Assembly134
  - Change134
- Left Front Shaft Hub Bolt139
  - Change139
- Left Rear Shaft Hub and Bearing Assembly140
  - Change140
- Left Rear Shaft Hub Bolt142
  - Change142
- Brake System143
  - Notes143
- Remove Malfunction144
  - Malfunction Phenomenon Table144
- Brake Liquid146
  - Discharge the Air in Brake System146
- Brake Pedal Assembly147
  - Adjustment147
  - Change148
- Vacuum Booster Assembly149
  - Inspection on Automobile149
  - Change149
- Front Brake Assembly152
  - Overhaul152
- Rear Brake Assembly155
  - Overhaul155
- Hydraulic Pressure Control Unit (Equipping with ABS)159
  - Inspection on Automobile159
  - Change159
- Speed Sensor of Front Wheel162
  - Change162
- Speed Sensor of Rear Wheels163
  - Change163
Parking Brake165
- Parking Brake System165
  - Malfunction Phenomenon Table165
  - Adjustment165
- Parking Brake Handle Assembly166
  - Change166
- Parking Front Bake Pull Cable Assembly167
  - Change167
- Parking Rear Brake Pull Cable Assembly169
  - Change169
- Parking Brake Assembly172
  - Overhaul172
Transmission Disassemble Assembly176
- Assemble the Assembly202
Steering Column Steering System203
- Note203
- Malfunction Phenomenon Table203
- Inspection on Automobile204
- Steering Column System205
  - Overhaul205
Power Steering209
- Power Steering System209
- Power Steering Oil Pump Assembly214
  - Overhaul214
- Power Steering Gear Assembly216
  - Overhaul216
Air Conditioner224
- Air Conditioning System224
- Refrigerant226
  - Inspection on Automobile226
  - Change232
- Refrigerant Pipeline233
  - Parts233
- Control Assembly, Air Conditioner Control Panel (AUTO A/C)234
  - Overhaul234
- Fan Assembly235
  - Overhaul235
- Air Conditioner Central Heating Core Assembly238
  - Overhaul238
- Compressor Assembly245
  - Change245
- Condenser Assembly247
  - Inspection on the Automobile247
  - Overhaul247
Supplemental Restraint System Note250
- Malfunction Treatment255
- Repair258
- Inspection260
- Remove Malfunction262
  - Malfunction Table262
  - Diagnosis of Impacted Automobile271
- Disassemble and Assemble272
Safety Belt281
- Note281
- Treatment281
- Subassembly284
- Change285
- Rear Safety Belt286
  - Subassembly286
  - Change288
Light290
- Light System290
- Front Combination Light (LH)297
- Front Fog Light300
- Side Turning Light302
  - Components302
- Rear Combination Light (LH)303
  - Components303
  - Change304
- Rear Fog Light305
  - Components305
  - Change306
- Number Plate Light307
  - Change307
- High Brake Light Assembly308
  - Change308
- Left Combination Switch309
  - Change309
Wiper and Cleaner310
- Wiper and Cleaner System310
- Right Combination Switch313
  - Change313
- Wiper Motor314
  - Change314
- Wiper316
  - Change316
- Cleaner Nozzle317
  - Adjustments317
Audio System Audio System318
- Notes318
- Radio Assembly319
  - Replacement319
- Left Front Door Loudhailer320
  - Change320
- Left Front Small Loudhailer321
  - Change321
- Rear Loudhailer322
  - Change322
- Outdoor Antenna323
  - Change323
Circuitry Power Supply324
- Components324
Horn System327
- Position327
- Inspect327
Windshield/Window Glass/Wing Mirror Electric Window Control System328
- Position Drawing328
- Inspect the Car328
- Malfunction Phenomena Table330
- Inspect330
- Front Windscreen332
  - Change332
- Rear Ventilation Window335
  - Change335
- Fog Defrost System338
- Electric Rearview Mirror Control System(Option)340
Panel / Combination Panel Combination Panel345
- Trouble Table345
- Vehicle Inspection346
- Inspection350
- Panel351
  - Preparation351
  - Change351
- Combination Instrument Assembly358
  - Disassembly and Assembly358
Chair359
- Front Chair359
- Rear Chair (Separating Type)363
  - Overhaul363
- Rear Chair (Fixing Type)365
  - Overhaul365
Anti-Stealing and Door Lock Electric Door Lock Control System366
- Position of Parts366
- Inspection on Automobile366
- Malfunction Phenomenon Table369
- Inspection370
- Electronic Anti-Stealing System372
Electric Sunroof373
- Sunroof373
  - Overhaul373
  - Specification for Sunroof Function375
Engine Cover/Automobile Door Engine Cover377
- Adjustment377
- Front Automobile Door378
- Rear Automobile Door384
  - Overhaul384
  - Adjustment386
- Trunk Cover388
  - Adjustment388
- Torsion Spring of Trunk Cover389
  - Change389
  - Subassembly390
Exterior/Inner Trim Board Front Bumper391
- Change391
- Rear Bumper392
  - Subassembly392
  - Change393
- Nameplate394
  - Change394
- Exterior Seal Tape of Left Front Door Glass (LH)395
  - Change395
- Exterior Seal Tape of Left Rear Door Glass396
  - Change396
- Light Fender397
  - Change397
- Top Left Trim Tape398
  - Replacement398
- Left Lower Fender of Automobile Body (LH)399
  - Subassembly399
  - Change400
- Inner Trim Board of Top401
  - Change401
Automobile Control System405
- Ignition Switch and Anti-Versa Lock Key Warning Switch405
  - Malfunction Phenomenon Table405
  - Inspection405
Electrical Schematic Diagram406
- Brake Light411

Geely FC - Page 231

Table of Contents

Related product manuals