2.20
MAINTENANCE
9924096 - 2013 RANGER RZR XP 900 / RZR XP 4 900 Service Manual
© Copyright 2012 Polaris Sales Inc.
11. Remove oil fill cap (see “Engine Oil Level”). Fill engine
with 2.5 quarts (2.4 L) of recommended engine oil.
12. Verify the transmission is still in PARK.
13. Start the engine and allow it to idle for 30 seconds.
14. Stop the engine and inspect for oil leaks. Wait at least
15 seconds before removing the dipstick.
15. Unlock the dipstick lever. Remove the dipstick and
wipe it dry with a clean cloth (see “Engine Oil Level”).
16. Reinstall the dipstick and push it into place. Do not
lock the dipstick
NOTE: Make certain the dipstick is inserted all the
way into the dipstick tube to keep the depth of the
dipstick consistent.
17. Remove the dipstick and check the oil level.
18. Add the recommended oil as necessary to bring the
oil level within the SAFE range on dipstick. Do not
overfill.
19. When finished, reinstall the oil fill cap, oil dipstick and
lock the lever.
20. Reinstall the cargo box access panel, engine service
panel and seats.
21. Dispose of used oil and filter properly.
Engine Crankcase Breather Hose Inspection
The engine crankcase is equipped with a breather hose.
Inspect the breather hose for possible kinks or wear. The
hose is form fitted for proper fit.
Follow the breather hose (A) from the crankcase to the
engine intake baffle box.
NOTE: Make sure hoses are not kinked or pinched.
Engine Cylinder Leakdown Test
A cylinder leak-down test is the best indication of engine
condition. Follow tester manufacturer’s instructions to
perform a cylinder leak-down test. Never use high
pressure leakage testers as crankshaft seals may
dislodge and leak.
Recommended Engine Oil:
PS-4 Plus Synthetic (PN 2876244)
Ambient Temp Range: -35° F to 100° F
PS-4 Extreme Duty Synthetic (PN 2878920)
Ambient Temp Range: 0° F to 120° F
Capacity: 2.5 Quarts (2.4 L)
Maintain Oil Level In SAFE Range
DO NOT Overfill the Engine
Cylinder Leakage Service Limit: 20%
If leakage exceeds service limit, inspect the
engine for the cause.
To Next Page
Loading...
Need help?
General
