CFMOTO
03-30
Item
Periodic Maintenance Intervals
(Perform at the interval that arrives rst)
Hour Calendar Miles (km) Remarks
Fuel lter and
hoses
100h 24M 2000 (3200)
Inspect routing and condition.
Replace lter and high-
pressure hoses every 4 years.
Cooling hoses 100h -- 1000 (1600) Inspect routing and condition.
► Valve clearance 100h -- 2000 (3200)
Inspect and adjust as
necessary. See dealer for
service.
● Fuel system 100h 12M 500 (800)
Inspect fuel tank, cap, fuel
pump and fuel pump relay.
Spark plug 100h 24M 2000 (3200)
Inspect; Replace if worn or
fouled.
■ Engine mounts 100h 12M 1500 (2400) Inspect condition.
Exhaust pipe and
spark arrestor
100h 12M 500 (800) Inspect. Clean spark arrestor.
►
Wiring, fuses,
connectors,
relays, and cables
100h 12M 1000 (1600)
Inspect wire routing for wear,
security. Apply dielectric
grease as necessary to
connectors subjected to water,
mud, etc.
► ■ Wheel bearings 100h 12M 1500 (2400)
Inspect for noise or looseness.
Replace as necessary.
► Safety Belts 100h 12M 2000 (3200)
Visually inspect belts and
test latches. Clean latch
mechanism more often if used
in severe conditions.Replace
as necessary.Replace as
necessary.
► Transmission oil 200h 12M 2000 (3200)
Inspect level. Change yearly
if hours or distance interval is
not met.
Coolant 200h 24M 4000 (6400)
Change coolant every 2 years
if hours or distance interval is
not met.
► Brake uid 200h 24M 1000 (1600)
Inspect uid for color change.
Change uid every two years.
Idle condition -- 12M --
Inspect for proper rpm. See
dealer for service if out of
spec or erratic.
■
Steering / Wheel
Alignment
-- 12M --
Inspect steering system. See
dealer for service whenever
steering parts or wheel
alignment are required.
► Foot brake height -- 12M --
Inspect. Replace brake pads
or adjust height as required.
© CFMOTO Powersports, Inc. This manual is subject to all applicable copyright laws.
Reproduction or duplication in any form, whole or in part, is strictly prohbited.
To Next Page