SEATS
Seat modules are made up of a seat frame, seat
cushion, seat back cushion, a covering material, and
the electrical components used for power operation, if
equipped. Some seat systems also contain seat belt
components and supplemental restraint systems.
Seat assemblies transport the occupants in comfort
and safety. Seat assemblies also help position occu-
pants correctly in the event of airbag deployment.
Seat cushions, coverings, and electrical components
are serviceable. Refer to the appropriate group in
this manual.
EXTERIOR COMPONENTS
Exterior sheet metal components make up the
exterior of the vehicle. Some exterior metal systems
are welded assemblies, such as doors and hoods.
Some exterior trim items are made of composite.
The exterior is finished in various metal stampings
and composite moldings. These assemblies give the
vehicle a finished appearance and protect the occu-
pants from the elements. Some components are part
of the energy absorbing system used to protect the
occupants in collisions. The exterior sheet metal is
repairable and adjustable for fit and finish. Welded
and bonded component systems are adjustable as a
system. Trim components made of composite are
stamped with the type of material used.
DaimlerChrysler uses various fasteners to retain
trim items. At times, it is not possible to remove trim
items without damaging the fastener. If it is not pos-
sible to remove an item without damaging a compo-
nent, cut or break the fasteners and use new ones
when installing the component.
SPECIFICATIONS
SPECIFICATIONS - LUBRICANT USAGE
ENGINE OIL
• Door Hinges – Hinge Pin and Pivot Contact
Areas
• Hood Hinges – Pivot Points
• Liftgate Hinges
• Decklid Hinges
MOPAR
T
SPRAY WHITE CUBE OR EQUIVALENT
• Door Check Straps
• Liftgate Latches
• Liftgate Prop Pivots
• Ash Receiver
• Fuel Filler Door Remote Control Latch Mecha-
nism
• Parking Brake Mechanism
• Sliding Seat Tracks
• Decklid Latch
MOPAR
T
Multipurpose GREASE OR EQUIVALENT
• All Other Hood Mechanisms
MOPAR
T
LOCK CYLINDER LUBRICANT OR
EQUIVALENT
• Door Lock Cylinders
• Decklid Lock Cylinder
23s - 2 BODY PL
BODY (Continued)
ProCarManuals.com
To Next Page
Loading...
