Epson AcuLaser C1100 - 1.13 Life details

EPSON AcuLaser C1100 Revision B
PRODUCT DESCRIPTION Life details 45
1.13 Life details
 Monochrome mode
Note : B:Monochrome C:Color
Note *1: 1. The life of a Photoconductor Unit may not reach the above numerical
value according to an operating condition.
It becomes a life end by full of the waste toner. (Because waste toner box is
included in a unit.)
The following are main factors to decrease the life.
z When area coverage exceeds about 10%
z When the power has been switched frequently
z Printing on special paper (Thick paper, Envelope, Transparencies)
2. The calculation for the life of Photoconductor is based on the following
conditions.
z Power-source ON/OFF is not considered.
z Calibration: 1 time /20pages
z Jam recovery operation at the time of Jam is included.
*2: The life may become below half if the user print on envelopes or thick paper
frequently.
(Excessive pressure is applied to a heat roll and wrinkles papers on the roll.)
 Color mode
Note : B:Monochrome C:Color
Note *1: 1. The life of a Photo Conductor unit may not reach the above numerical
value according to an operating condition.
It becomes a life end by full of the waste toner. (Because waste toner box is
included in a unit.)
The following are main factors to decrease the life.
z When area coverage exceeds about 10%
z When the power has been switched frequently
z Printing on special paper (Thick paper, Envelope, Transparencies)
2. The calculation for the life of Photoconductor is based on the following
conditions.
z Power-source ON/OFF is not considered.
z Calibration: 1 time /20pages
z Jam recovery operation at the time of Jam is included.
*2: The life may become below half if the user print on envelopes or thick paper
frequently.
(Excessive pressure is applied to a heat roll and wrinkles papers on the roll.)
Table 1-33. Monochrome mode
Unit
Catalog
specification
value
Area
Coverage
Printing
speed mode
LIFE (unit: pages)
Continuous
printing
4p/J 1p/J
Photoconductor
Unit*
1
Monochrome
Continuation
42,000page
14,000page
2p/J
B:C=1:2
5%
Standard 42,000 39,400 20,900
Low speed 12,500 11,500 9,200
10%
Standard 42,000 38,500 20,500
Low speed 12,500 11,500 9,200
20%
Standard 31,000 31,000 20,000
Low speed 12,400 11,500 9,100
Toner Cartridge
4,000 5% --- 4,000 4,000 4,000
1,500 5% --- 1,500 1,500 1,500
FUSER ASSY*
2
100,000 --- Standard 100,000
100,000
(TBD)
(TBD)
HOUSING
ASSY-DEVE K
100,000 --- --- 100,000 100,000 100,000
2ND BTR
ASSY
100,000 --- --- 100,000 100,000 100,000
Table 1-34. Color mode
Unit
Catalog
specification
value
Area
Coverage
Printing
speed mode
LIFE (unit: pages)
Continuous
printing
4p/J 1p/J
Photoconductor
Unit*
1
Color
Continuation
10,500page
14,000page
2p/J
B:C=1:2
5%
Standard 10,500 10,500 10,500
Low speed 7,900 7,500 6,400
10%
Standard 10,500 10,500 10,300
Low speed 7,800 7,400 6,300
20%
Standard 5,300 5,300 5,300
Low speed 5,300 5,300 5,300
Toner Cartridge
4,000 5% --- 4,000 4,000 4,000
1,500 5% --- 1,500 1,500 1,500
FUSER ASSY*
2
100,000 --- Standard 100,000
100,000
(TBD)
(TBD)
HOUSING
ASSY-DEVE
Y/M/C
100,000 --- --- 66,700 66,700 66,700
2ND BTR
ASSY
100,000 --- --- 100,000 100,000 100,000