Extra 300LT - Page 57

CHAPTER 5
PAGE 18
PAGE DATE: 12. June 2015
MAINTENANCE MANUAL EXTRA 300LT
Inspector:
Mechanic:
Date:
Serial No.:
Inspections
as specif
i
ed
eac
h
50 hours
eac
h
100 hours
O
1
57 Overhaul or replace propeller governor as required.
O
2
58 Complete overhaul of engine or replace with factory re-
built.
Fuselage
O O 1 Remove tail fairing, tail side skins, main fuselage cover and
landing gear cuffs per chapters 51 and 53.
O 2 Remove bottom fuselage cover including exhaust area
covering sheet per chapter 53.
O O 3 Inspect main and bottom fuselage cover including exhaust
area covering sheet, tail fairing, tail side skins and landing
gear cuffs for general condition, dents, cracks and loose
screws.
O O 4 Inspect baggage compartment structure for cracks and
damage.
O O 5 Inspect baggage net and tie-down straps for security,
attachment, proper operation and condition.
O O 6 Check installed parts for general condition and security of
attachment.
O O 7 Inspect fuselage for foreign objects.
O 8 Inspect steel tube construction for general condition, cor-
rosion and cracks, above all in areas of load stress (e.g.
wing, stabilizer, engine and seat attachments).
O O 9 Visually inspect steel tube construction in the area of hori-
zontal stabilizer attachment brackets for cracks. In case of
doubt remove horizontal stabilizer and use a dye check
penetrant. In case cracks are found contact EXTRA-
Flugzeugproduktions- und Vertriebs- GmbH for repair
advice.
O O 10 Inspect fabric cover for general condition.
SCHEDULED MAINTENANCE CHECKS
Maintenance Checks Schedule
1 refer to Woodward Service Bulletin No. 33580 or applicable MT-Propeller Instructions
2 refer to Lycoming Service Instruction No. 1009