Geely FC - Page 184

To Next Page

To Previous Page

Disassemble shift guide shaft and dust-proof cover from shift

cover, and take down gasket liking that shown in figure.

Take out the shift cover oil seal with wrench liking that shown

in figure

Take out the other oil seal on shift cover with same method.

Transmission—Disassemble assembly

 173 

Main Page

Default Chapter6
- Table of Contents6
Brief Introduction on Geely Model “FC”12
- Brief Introduction on Geely Model "FC" Basic Parameters12
Maintenance Period Regular Maintenance Items15
Engine Control System EFI System19
- On-Vehicle Inspection19
- Inspection20
- Throttle Body Assembly24
  - Removing, Installing and Disassembling, Assembling24
Fuel25
- Fuel System25
- Injection Nozzle Assembly29
  - Replacement29
- Fuel Pump Assembly31
  - Removing, Installing and Disassembling, Assembling31
- Fuel Tank Assembly32
  - Removing, Installing and Disassembling, Assembling32
Exhaust Gas Control34
- Exhaust Gas Control System34
  - On-Vehicle Inspection34
  - Inspection36
Engine Mechanism Engine Assembly37
- Inspection37
- Drive Belt40
  - Replacement40
- Valve Clearance41
  - Adjustment41
- Engine Assembly47
  - Replacement47
- Timing Chain Assembly56
  - Replacement56
- Camshaft63
  - Replacement63
- Crankshaft Front Oil Seal Assembly71
  - Replacement71
- Crankshaft Rear Oil Seal Assembly73
  - Replacement73
- Cylinder Cover Gasket Components74
  - Replacement74
Exhaust76
- Exhaust Pipe Assembly76
  - Removing, Installing and Disassembling, Assembling76
Cooling Cooling System77
- On-Vehicle Inspection77
- Inspection77
- Cooling Fan System79
  - On-Vehicle Inspection79
  - Inspection79
- Water Pump Assembly80
  - Replacement80
- Temperature Regulator Components82
  - Replacement82
- Radiator with Electronic Fan Assembly83
  - Replacement83
- Coolant84
  - Replacement84
Lubrication Lubricating System85
- On-Vehicle Inspection85
- Oil Filter Assembly86
  - Replacement86
- Oil Pump Assembly87
  - Replacement87
Ignition Ignition System88
- Inspection88
- On-Vehicle Inspection88
Starting and Charging Starting System90
- Inspection90
- Charging System92
  - Precautions92
  - On-Vehicle Inspection93
- Alternator Components95
  - Replacement95
  - Starter Components96
    - Replacement96
Front Suspension97
- Front Suspension System97
- Front Wheel Alignment98
  - Adjustment98
- Front Absorber and Helical Spring101
  - Overhaul101
  - Handling104
- Lower Left Control Arm Assembly105
  - Replacement105
- Front Stabilizer Bar107
  - Overhaul107
- Front Left Lower Control Arm Ball Joint Assembly110
  - Replacement110
Rear Suspension111
- Rear Suspension System111
- Rear Wheel Alignment112
  - Adjustment112
- Rear Strut Assembly113
  - Overhaul113
  - Handling115
- Rear Stabilizer Bar116
  - Overhaul116
- Rear Shaft Assembly117
  - Overhaul117
Tire and Wheel120
- Wheel and Tire System120
  - Inspection120
Drive Shaft Drive Shaft122
- Notes122
- Malfunction Phenomenon Table122
- Inspection on Automobile123
- Front Drive Shaft124
  - Overhaul124
- Left Front Shaft Hub Assembly134
  - Change134
- Left Front Shaft Hub Bolt139
  - Change139
- Left Rear Shaft Hub and Bearing Assembly140
  - Change140
- Left Rear Shaft Hub Bolt142
  - Change142
- Brake System143
  - Notes143
- Remove Malfunction144
  - Malfunction Phenomenon Table144
- Brake Liquid146
  - Discharge the Air in Brake System146
- Brake Pedal Assembly147
  - Adjustment147
  - Change148
- Vacuum Booster Assembly149
  - Inspection on Automobile149
  - Change149
- Front Brake Assembly152
  - Overhaul152
- Rear Brake Assembly155
  - Overhaul155
- Hydraulic Pressure Control Unit (Equipping with ABS)159
  - Inspection on Automobile159
  - Change159
- Speed Sensor of Front Wheel162
  - Change162
- Speed Sensor of Rear Wheels163
  - Change163
Parking Brake165
- Parking Brake System165
  - Malfunction Phenomenon Table165
  - Adjustment165
- Parking Brake Handle Assembly166
  - Change166
- Parking Front Bake Pull Cable Assembly167
  - Change167
- Parking Rear Brake Pull Cable Assembly169
  - Change169
- Parking Brake Assembly172
  - Overhaul172
Transmission Disassemble Assembly176
- Assemble the Assembly202
Steering Column Steering System203
- Note203
- Malfunction Phenomenon Table203
- Inspection on Automobile204
- Steering Column System205
  - Overhaul205
Power Steering209
- Power Steering System209
- Power Steering Oil Pump Assembly214
  - Overhaul214
- Power Steering Gear Assembly216
  - Overhaul216
Air Conditioner224
- Air Conditioning System224
- Refrigerant226
  - Inspection on Automobile226
  - Change232
- Refrigerant Pipeline233
  - Parts233
- Control Assembly, Air Conditioner Control Panel (AUTO A/C)234
  - Overhaul234
- Fan Assembly235
  - Overhaul235
- Air Conditioner Central Heating Core Assembly238
  - Overhaul238
- Compressor Assembly245
  - Change245
- Condenser Assembly247
  - Inspection on the Automobile247
  - Overhaul247
Supplemental Restraint System Note250
- Malfunction Treatment255
- Repair258
- Inspection260
- Remove Malfunction262
  - Malfunction Table262
  - Diagnosis of Impacted Automobile271
- Disassemble and Assemble272
Safety Belt281
- Note281
- Treatment281
- Subassembly284
- Change285
- Rear Safety Belt286
  - Subassembly286
  - Change288
Light290
- Light System290
- Front Combination Light (LH)297
- Front Fog Light300
- Side Turning Light302
  - Components302
- Rear Combination Light (LH)303
  - Components303
  - Change304
- Rear Fog Light305
  - Components305
  - Change306
- Number Plate Light307
  - Change307
- High Brake Light Assembly308
  - Change308
- Left Combination Switch309
  - Change309
Wiper and Cleaner310
- Wiper and Cleaner System310
- Right Combination Switch313
  - Change313
- Wiper Motor314
  - Change314
- Wiper316
  - Change316
- Cleaner Nozzle317
  - Adjustments317
Audio System Audio System318
- Notes318
- Radio Assembly319
  - Replacement319
- Left Front Door Loudhailer320
  - Change320
- Left Front Small Loudhailer321
  - Change321
- Rear Loudhailer322
  - Change322
- Outdoor Antenna323
  - Change323
Circuitry Power Supply324
- Components324
Horn System327
- Position327
- Inspect327
Windshield/Window Glass/Wing Mirror Electric Window Control System328
- Position Drawing328
- Inspect the Car328
- Malfunction Phenomena Table330
- Inspect330
- Front Windscreen332
  - Change332
- Rear Ventilation Window335
  - Change335
- Fog Defrost System338
- Electric Rearview Mirror Control System(Option)340
Panel / Combination Panel Combination Panel345
- Trouble Table345
- Vehicle Inspection346
- Inspection350
- Panel351
  - Preparation351
  - Change351
- Combination Instrument Assembly358
  - Disassembly and Assembly358
Chair359
- Front Chair359
- Rear Chair (Separating Type)363
  - Overhaul363
- Rear Chair (Fixing Type)365
  - Overhaul365
Anti-Stealing and Door Lock Electric Door Lock Control System366
- Position of Parts366
- Inspection on Automobile366
- Malfunction Phenomenon Table369
- Inspection370
- Electronic Anti-Stealing System372
Electric Sunroof373
- Sunroof373
  - Overhaul373
  - Specification for Sunroof Function375
Engine Cover/Automobile Door Engine Cover377
- Adjustment377
- Front Automobile Door378
- Rear Automobile Door384
  - Overhaul384
  - Adjustment386
- Trunk Cover388
  - Adjustment388
- Torsion Spring of Trunk Cover389
  - Change389
  - Subassembly390
Exterior/Inner Trim Board Front Bumper391
- Change391
- Rear Bumper392
  - Subassembly392
  - Change393
- Nameplate394
  - Change394
- Exterior Seal Tape of Left Front Door Glass (LH)395
  - Change395
- Exterior Seal Tape of Left Rear Door Glass396
  - Change396
- Light Fender397
  - Change397
- Top Left Trim Tape398
  - Replacement398
- Left Lower Fender of Automobile Body (LH)399
  - Subassembly399
  - Change400
- Inner Trim Board of Top401
  - Change401
Automobile Control System405
- Ignition Switch and Anti-Versa Lock Key Warning Switch405
  - Malfunction Phenomenon Table405
  - Inspection405
Electrical Schematic Diagram406
- Brake Light411

Geely FC - Page 184

Table of Contents

Related product manuals