Repair information 4-59
5060-4xx
Pick rolls
Go to “Pick roll tires” on page 7-53 for part number.
Front roll
1.
Wipe any toner or debris from the bottom pan to avoid contaminating the pick rolls.
2. Pull the pick assembly down into the bottom pan and remove the screw.
Note: Do not attempt to remove either the shaft or the clutch races.
Rear roll
Reach around and depress the latch on the side of the shaft and remove the roll.
Installation notes:
•
Replace both rolls at the same time.
• When you replace the front roll, make sure the roll is pressed against the shaft and the screw is fastened all
the way down.
• When replacing both the front and back rolls, note the directional markings on the roll and make sure the
rolls turn clockwise when viewed from the front. Check out the directional arrows in the pictures. Verify the
rolls turn freely.
To Next Page
Loading...
