PREVOST X3-45 Multiplex User Manual

Section 05: COOLING SYSTEM
PA1562
11
5.6 COOLANT RECOMMENDATIONS FOR
VOLVO D13 ENGINE
Coolant mixture consisting of 50/50 antifreeze
and deionized water solution should be used
year-round to provide freeze and boil-over
protection as well as providing a stable
environment for seals and hoses.
When topping up coolant, use the same coolant
mixture type as the mixture already in the
cooling system. Do not mix two different types of
coolant.
Do not use antifreeze formulated for automobile
gasoline engines, these have a very high silicate
content that will clog the radiator and leave
unwanted deposits in the engine.
A decal (053487) located on the surge tank
provides information on recommended coolants.
Recommended coolants for Volvo D13
engine:
• Prevost #685241 (pre-diluted 50/50
mixture);
• Texaco CPS#227998 (pre-diluted 50/50
mixture);
• Chevron CPS#2227805 (pre-diluted 50/50
mixture);
• Volvo 20358716 (pre-diluted 50/50
mixture);
CAUTION
On Volvo D13 engine, use only Extended Life
Coolant (ELC). Do not add supplemental
coolant additives (SCA) to extended life
coolant. Do not use a coolant filter containing
Supplemental Coolant Additives (SCA).
CAUTION
Extended Life Coolant (ELC) will test as out of
additives (SCA), but SCA should not be
added. Shortened engine life may be the
result of adding SCA.
FIGURE 14: LOCATION OF HEATER LINE SHUT-OFF VALVES IN ENGINE COMPARTMENT 05105

PREVOST X3-45 Multiplex Specifications

General

Length	45 ft
Width	102 in
Engine	Volvo D13
Horsepower	500 hp
GVWR	54, 000 lbs
Height	146 in
Sleeping Capacity	Varies based on floor plan
Water Capacity	Varies based on floor plan