PREVOST X3-45 Multiplex User Manual

Section 01: ENGINE
PA1562
2
ILLUSTRATIONS
F
IGURE 1: ENGINE SENSORS LOCATION.............................................................................................................6
FIGURE 2: D13F ENGINE, TURBO SIDE (TYPICAL)................................................................................................7
FIGURE 3: D13F ENGINE, ALTERNATOR SIDE (TYPICAL).......................................................................................8
FIGURE 4: D13F OIL FILTERS ............................................................................................................................9
FIGURE 5: OIL FILTER WRENCH .......................................................................................................................11
FIGURE 6: OIL FITER REPLACEMENT ................................................................................................................11
FIGURE 7: ENGINE OIL FILLING TUBE................................................................................................................12
FIGURE 8: ENGINE OIL LEVEL DIPSTICK............................................................................................................12
FIGURE 9: COOLER POSITION DURING ENGINE CRADLE INSERTION OR REMOVAL ................................................13
FIGURE 10: BELT TENSIONER VALVE ...............................................................................................................13
FIGURE 11: ENGINE COMPARTMENT X3 COACHES (TYPICAL).............................................................................15
FIGURE 12: NORMAL OIL COOLER POSITION.....................................................................................................15
FIGURE 13: VOLVO ENGINE POWER PLANT CRADLE INSTALLATION.....................................................................16
FIGURE 14: VEHICLE INTERFACE HARNESS (GENERAL APPLICATION SHOWN).....................................................18
FIGURE 15: DETROIT DIESEL 2007 SERIES 60 ENGINE (TYPICAL) .........................................................20
FIGURE 16: MOTOR CONTROL MODULE (MCM) .................................................................................................21
FIGURE 17: CPC ............................................................................................................................................21
FIGURE 18: THE CPC COMMUNICATES OVER THE J1587 AND J1939 DATA LINKS TO THE VEHICLE........................21
FIGURE 19: FLASHING FAULTS CODES.............................................................................................................23
FIGURE 20: ENGINE OIL LEVEL DIPSTICK..........................................................................................................42
FIGURE 21: OIL RESERVE TANK.......................................................................................................................42
FIGURE 22: ENGINE DRAIN PLUG AND OIL FILTERS............................................................................................43
FIGURE 23: BELT TENSIONER VALVE ...............................................................................................................44
FIGURE 24: ENGINE COMPARTMENT X3 COACHES (TYPICAL).............................................................................46
FIGURE 25: DDC SERIES 60 POWER PLANT CRADLE INSTALLATION ....................................................................47
FIGURE 26: ELECTRONIC FOOT PEDAL ASSEMBLY ............................................................................................48

PREVOST X3-45 Multiplex Specifications

General

Length	45 ft
Width	102 in
Engine	Volvo D13
Horsepower	500 hp
GVWR	54, 000 lbs
Height	146 in
Sleeping Capacity	Varies based on floor plan
Water Capacity	Varies based on floor plan