PREVOST X3-45 Multiplex User Manual

Section 07: TRANSMISSION
PA1562
2
11. SPECIFICATIONS...........................................................................................................................32
ILLUSTRATIONS
FIGURE 1: ALLISON TRANSMISSION ...................................................................................................................3
FIGURE 2: ALLISON TRANSMISSION CONTROL PAD..............................................................................................3
FIGURE 3: ZF-ASTRONIC TRANSMISSION............................................................................................................4
FIGURE 4: OIL LEVEL DIPSTICK (AUTO. TRANS.) .................................................................................................4
FIGURE 5: COLD CHECK ...................................................................................................................................5
FIGURE 6: HOT CHECK .....................................................................................................................................5
FIGURE 7: DRAIN PLUG AND FILTERS ...............................................................................................................13
FIGURE 8: RELEASE BEARING RETAINING CLIP .................................................................................................14
FIGURE 9: ZF OR ALLISON TRANSMISSION BRACKETS........................................................................................15
FIGURE 10: ENGINE CRANKING POSITION.........................................................................................................16
FIGURE 11: VOLVO ENGINE CRANKING POSITION..............................................................................................16
FIGURE 12: MODINE OIL COOLER ....................................................................................................................17
FIGURE 13: COOLER WITH RETARDER .............................................................................................................18
FIGURE 14: ALLISON OIL COOLER....................................................................................................................18
FIGURE 15: AIR PRESSURE REGULATOR (TYPICAL)...........................................................................................20
FIGURE 16: TRANSMISSION CONTROL MODULE ................................................................................................20

PREVOST X3-45 Multiplex Specifications

General

Length	45 ft
Width	102 in
Engine	Volvo D13
Horsepower	500 hp
GVWR	54, 000 lbs
Height	146 in
Sleeping Capacity	Varies based on floor plan
Water Capacity	Varies based on floor plan