PREVOST X3-45 Multiplex User Manual

TABLE A
DISTANCE TRAVELED
1
(miles / km)
6 250 / 10 000 12 500 / 20 000 18 750 / 30 000 25 000 / 40 000 31 250 / 50 000 37 500 / 60 000 43 750 / 70 000 50 000 / 80 000 56 250 / 90 000 62 500 / 100 000 68 750 / 110 000 75 000 / 120 000 81 250 / 130 000 87 500 / 140 000 93 750 / 150 000 100 000 / 160 000 106 250 / 170 000 112 500 / 180 000 118 750 / 190 000 125 000 / 200 000 131 250 / 210 000 137 500 / 220 000 143 750 / 230 000 150 000 / 240 000 185 000 / 300 000 200 000 / 320 000 225 000 / 360 000 250 000 / 400 000 275 000 / 440 000 300 000 / 500 000 500 000 / 800 000 600 000 / 1 000 000
LUBRICATION AND
SERVICING SCHEDULE
Item Months
proceed to maintenance operation at each
LUBRICANT /PART
2
07 TRANSMISSION
8
Transmission oil cooler, replace unit if vehicle is equipped with
transmission retarder
24
ZF-Astronic Automatic Transmission, change fluid & filter
16 24
●
J
09 PROPELLER SHAFT
Grease one fitting on each universal joint and slip joint
34 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
11 REAR AXLE
Differential, check oil level, add if necessary
35
● ● ● ● ● ●
E
Differential, change oil, clean breathers
35
●
E
Differential, change oil, clean breathers (with full synthetic oil)
35
●
E
Tag axle lever pivot, grease one fitting on each pivot
15 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
12 BRAKE & AIR
Air tanks, drain water from all tanks
12
● ● ● ● ● ● ● ● ● ● ● ●
Accessories air filter, change filter element
3 24
●
P17
Air dryer, change cartridge
36 24
●
P18
Brake pads, check pad wear indicator and perform caliper
slide check (Min. tickness 3/32 in or 2mm)
12
● ● ● ● ● ● ● ● ● ● ● ●
13 WHEELS, HUBS & TIRES
Hub unit and swivel assembly, Maintenance Manual sec.13
See GKN AXLE LTD Service Manual paragraph 1-Lubrication
-
● ● ● ● ● ●
8
Allison Transmission recommends that customers use fluid analysis as the primary method for determining fluid change intervals. In the absence of a fluid analysis program, the fluid
change interval listed in the charts above and below should be used. Change filters according to the charts above and below even is a fluid analysis shows that the fluid doesn’t need
to be changed.

PREVOST X3-45 Multiplex Specifications

General

Length	45 ft
Width	102 in
Engine	Volvo D13
Horsepower	500 hp
GVWR	54, 000 lbs
Height	146 in
Sleeping Capacity	Varies based on floor plan
Water Capacity	Varies based on floor plan