PREVOST X3-45 Multiplex User Manual

TABLE A
DISTANCE TRAVELED
1
(miles / km)
6 250 / 10 000 12 500 / 20 000 18 750 / 30 000 25 000 / 40 000 31 250 / 50 000 37 500 / 60 000 43 750 / 70 000 50 000 / 80 000 56 250 / 90 000 62 500 / 100 000 68 750 / 110 000 75 000 / 120 000 81 250 / 130 000 87 500 / 140 000 93 750 / 150 000 100 000 / 160 000 106 250 / 170 000 112 500 / 180 000 118 750 / 190 000 125 000 / 200 000 131 250 / 210 000 137 500 / 220 000 143 750 / 230 000 150 000 / 240 000 185 000 / 300 000 200 000 / 320 000 225 000 / 360 000 250 000 / 400 000 275 000 / 440 000 300 000 / 500 000 500 000 / 800 000 600 000 / 1 000 000
LUBRICATION AND
SERVICING SCHEDULE
Item Months
proceed to maintenance operation at each
LUBRICANT /PART
2
14 STEERING
Drag link ends, grease one fitting at each end
4 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
Relay rod ends, grease one fitting at each end
42 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
Steering tie rod ends, grease one fitting at each end
40 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
Idler arm, grease fitting
41 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
Bell crank, grease fitting
41 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
Steering damper cylinder, grease one fitting at rod end
39 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
Steering knuckle pins, grease two fittings per knuckle
9 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
K
Power steering reservoir, replace oil and filter cartridges
29 12
● ● ●
B
16 SUSPENSION
Upper A-Arm Ball Joint, grease fitting
6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
L
Air bellows, inspect
6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
22 HEATING & AIR CONDITIONING
A/C compressor, check oil level, add if necessary
25 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
D
A/C receiver tank, check refrigerant level, add if necessary
37 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
Refrigerant moisture indicator, replace filter dryer unit
according to moisture indicator (as needed)
38 6
● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ● ●
A/C and Heating air filters, clean or replace all elements
10 6
● ● ● ● ● ● ● ● ● ● ● ●
P14,P15
Parcel rack fan air filters, clean or replace
- 6
● ● ● ● ● ● ● ● ● ● ● ●
P20
Condenser discharge tube, qty:2, check to see if clogged
9
- 3
Front discharge tube, qty:2, check to see if clogged
10
-3
Evaporator discharge tube, qty:6, check to see if clogged
- 3
Recirculating pump drive motor, inspect brush, replace if
necessary
- 12
● ● ● ●
9
Discharge tubes are rubber tubes located under vehicle
10
Discharge tubes are rubber tubes located under vehicle

PREVOST X3-45 Multiplex Specifications

General

Length	45 ft
Width	102 in
Engine	Volvo D13
Horsepower	500 hp
GVWR	54, 000 lbs
Height	146 in
Sleeping Capacity	Varies based on floor plan
Water Capacity	Varies based on floor plan