HOEFLON C30e - User Manual

To Next Page

User Guide

C30e Compact crane

Translation of the original instructions

Serial no.:

Delivery date:

Reference: U.C30e.00.00.EN

Version: 1.0

Main Page

Table of Contents3
Revision Control9
Property Rights9
Preface10
General Terms & Conditions10
Warranty and Liability10
Target Audience11
Warning Icons11
Structure of the User Manual11
Introduction13
Intended Use13
EC Declaration14
Type Plate14
Safety15
Introduction15
Notes on the Safety Features15
General16
110% Button16
Personnel16
Work Environment17
During Setup18
While Working18
During Lifting19
Working with Long Loads20
Moving the Crane20
Electrical21
After Work22
Emergency Stop22
Rated Capacity Limiter (RCL)22
Pictograms23
Technical Data25
Dimensions25
Center of Gravity26
With Jib26
No Jib27
Specifications27
Basic Data27
Crane and Component Weights27
Maximum Loads27
Maximum Lean Angles28
Fly Jib28
Winch28
Environmental Conditions28
Undercarriage28
Electrical System29
Hydraulic System29
Remote Control29
Description31
Main Components32
Boom33
Counterweight34
Outriggers34
Accessories35
Winch35
Fly Jib36
Lifting Attachments36
Lifting Adapter and Hook37
Angle Adapter37
Searcher Hook38
Winch Head38
Storage Compartments40
Charging Cables41
Controls41
Rear Compartment42
Remove the Cover of the Compartment at the Rear of the Crane42
Overview43
Carrier Arms43
Work Lights44
Stack Lights45
Spirit Levels45
Remote Control47
Introduction47
Buttons48
Control Buttons for the Compact Crane48
Navigation Panel50
110% Button50
Driving Speed50
Undercarriage / Superstructure Toggle Button51
Work Light51
Levers52
Default Configuration52
Calibration56
Function Mapping59
Display61
While Controlling the Undercarriage61
Pick up Mode63
Pick and Carry Mode65
While Controlling the Superstructure65
Pick up Mode68
Pick and Carry Mode69
Connect with the Crane70
The LED Does Not Flash71
The LED Stops Flashing and Goes off71
Replacing and Charging the Remote Control Battery71
Care of the Battery Pack73
Introduction73
Charge Indicator73
Charging the Battery Pack74
Installation77
Daily Inspection (Inspection before Use)77
Starting and Stopping the Crane78
Starting the Crane78
Stopping the Crane79
Setting the Width of the Crawler Track79
Setting the Track State80
Moving the Crane81
Using the Controls81
Maximum Slope Angles When Moving the Crane82
Setting the Outriggers83
Preparation83
How to Set the Outriggers83
Using the Outrigger Extensions85
Setting the Counterweight86
Preparation86
How to Set the Counterweight86
Pick up Mode87
The Jib87
Installing the Jib87
Removing the Jib89
Attaching an Attachment90
Lifting Adapter and Hook90
Angle Adapter92
Searcher Hook93
Winch Head93
Prepare the Crane for Use with the Winch94
Identify the Winch95
Move the Winch Cable in Position97
Attaching the Hook Block99
Reeving with the Winch Head103
Attaching the Hook Block with 2 X Reeving104
Extending a Carrier Arm108
Operation111
Planning the Lift111
Different Ways to Lift a Load111
Guiding the Load112
Bridging Device112
Emergency Stop113
Location113
Operation113
Error Codes113
Restart the Crane after an Emergency Stop113
Boom and Jib Section Interlock114
Activating the Boom Section Interlock114
Removing the Boom Section Interlock115
Activating the Jib Section Interlock115
Removing the Jib Section Interlock116
Lifting the Load with the Boom116
Controls117
Maximum Angle of the Boom When Lifting with the Hook117
Lifting with the Jib118
Controls118
Maximum Angle of the Jib When Lifting with the Hook119
Searcher Hook Positions in the Angle Adapter119
Maximum Angle of the Jib with the Searcher Hook120
Remove the Winch Roll120
Lifting with the Jib and the Winch121
Winch Head Positions in the Angle Adapter121
Maximum Angle of the Jib with the Angle Adapter122
Pick and Carry" Mode122
Enter "Pick and Carry" Mode Without Lifting a Load123
Enter "Pick and Carry" Mode While Lifting123
Reducing the Height of the Crane124
Turn the Winch down Next to the Boom124
Turn the Winch to the Upright Position125
Removing and Installing the Counterweight126
Remove the Counterweight126
Install the Counterweight130
Maintenance135
Introduction135
Maintenance Work136
First Use136
Scheduled Servicing136
Safety During Maintenance136
Maintenance Schedule138
General138
Crawler Track Undercarriage139
Hydraulic System140
Electrical System140
Hydraulic System141
Lubricants141
Inspect the Oil Level141
Fill the Oil Tank142
Lubrication142
Every 50 Hrs145
Plastic Wear Strips of the Counterweight145
Plastic Wear Strips on the Track Extenders145
Grease Nipples on the Drive of the Slewing Ring146
Every 100 Hrs147
Chain Maintenance147
Lubricate the Chains147
Crawler Tracks147
Inspect the Tension147
Loosen a Crawler Track148
Tighten a Crawler Track149
Troubleshooting151
The Remote Control Cannot Connect with the Crane151
The LED Does Not Flash151
The LED Stops Flashing and Goes off151
Charging the 24V Batteries151
Error Codes - 20240206152
Fuses and Relays158
Replace a Broken Fuse or Relay158
Fuses159
Transport and Storage161
Transporting a Crane161
Put the Crane in Transport Position161
Put the Crane on the Transport Vehicle162
Securing the Crane for Transport162
Lifting the Crane164
Putting the Compact Crane in Storage164
Putting the Crane in Storage Without a Charging Facility165
Disposal167
Dispose of the C30E Compact Crane167
Waste Disposal167
Appendix169
Load Chart - Counterweight170
Load Chart - Pick and Carry171
Load Chart with Boom and Jib Section Interlocks172

Need help?

Do you have a question about the HOEFLON C30e and is the answer not in the manual?

HOEFLON C30e Specifications

General

Brand	HOEFLON
Model	C30e
Category	Construction Equipment
Language	English

HOEFLON C30e - User Manual

Table of Contents

HOEFLON C30e Specifications