System Overview
2-63
Image Chain
Overview
The following diagram is the image chain pipeline of Brivo715/785/865.
Collimator collimates the X-ray beam to the appropriate field size and user’s setting. The x-ray beam passes
through Grid to reduce scattered X-ray photons. Image Intensifier converts this X-ray into lights for each field size
selection, and sends the light to CCD Camera head. CCD Camera head captures the light image and sends the
digital video data by Gigabit LAN to Network card. Network card input digital video to CPU, and the CPU performs
real-time post-processing (Brightness, Contrast, Edge Enhance, Zoom, and Negate) to be sent to image display.
CPU also analyzes the digital video signal, and outputs a video level indicator (VLI) to MCB; higher VLI when the X-
ray dose is higher than desired, and lower VLI when the X-ray dose is lower than desired. With AutoTechnique
enabled, VLI will be processed by MCB S/W, and commands will be sent to X-ray Generator and GigE Camera to
change kVp/mA/gain depending on the VLI value. Finally the optimized image and exposure technique are
produced.
Collimator Control
Collimator:
The collimator is an electromechanical assembly designed to allow the operator to restrict the size and
shape of the X-ray beam. The unit has a lead iris and shutters and is mounted directly over the X-ray tube
beam aperture. There are 3 motions in collimator: iris open/close; shutter open/close; shutter rotation.
- The diameter of the iris aperture
- The gap spacing between the semi-transparent copper leaves
- The rotational position/orientation of the copper leaves
Collimator specification:
- Length×Width×Height: 180 mm×130 mm×95 mm
- Weight: 1.65kg
- 8 leaves motorized iris collimator
- 2 blades motorized shutter
- Shutter rotate angle: 360 degree
Collimator Control:
Overview
Collimator control subsystem is responsible for collimator motion control and status feedback. It consists of
Mother Board/MCB/CCB/collimator/cables between them and firmware in MCB.
X
-
ray Generation
X-ray Detection
Image Acquisition
Image Processing
Image Display
Grid
X-rays
LightX-rays
Digital 12 bit
Gigabit Lan
Digital
8 bit
GigE
Camera
Network
card
I.I
IP
CPU/
display
Left 19"
color/mono
LCD
Digital
12 bit
JPI (715,785)
Dunlee (865)
Thales
JHI: 1M Camera
Bigtide
X-ray
Gen
VLI
(kV, mA)
OEC 40kHz
Exposure
Manage
Gain
To Next Page
Loading...
