Yamaha F15A - Periodic Inspection and Adjustment

CHAPTER 3
PERIODIC INSPECTION AND ADJUSTMENT
MAINTENANCE INTERVAL CHART.............................................................3-1
PERIODIC SERVICE.......................................................................................3-2
INSPECTION AND ADJUSTMENT COWLING.......................................3-2
Water separator drain hole...............................................................3-2
FUEL SYSTEM.........................................................................................3-2
Fuel line..............................................................................................3-2
Fuel filter replacement ......................................................................3-2
CONTROL SYSTEM.................................................................................3-3
Throttle cables adjustment (MH/EH models) ..................................3-3
Remote control throttle cable adjustment (E models) ...................3-4
Throttle link lever adjustment ..........................................................3-5
Remote control shift cable adjustment (E models) ........................3-6
Shift cable adjustment (FT9.9DMH, FT9.9DEH).......................................3-7
Engine idling speed adjustment (For USA).....................................3-8
Engine idling speed is adjustment (except for USA)......................3-8
Start-in-gear protection device adjustment (MH models) ...........3-10
POWER UNIT.........................................................................................3-11
Engine oil level ................................................................................3-11
Engine oil replacement ...................................................................3-11
Timing belt .......................................................................................3-12
Valve clearance ................................................................................3-12
Ignition timing check.......................................................................3-14
LOWER UNIT .........................................................................................3-15
Gear oil.............................................................................................3-15
Lower unit leakage check................................................................3-16
Trim tab check (for S-transom model)...........................................3-16
GENERAL...............................................................................................3-16
Anode ...............................................................................................3-16
Battery (EH/E models) .....................................................................3-17
Spark plugs ......................................................................................3-18
Compression pressure measurement ...........................................3-19
Lubrication points............................................................................3-21
E
INSP
ADJ