Yamaha F15A - Maintenance Interval Chart

INSP
ADJ
MAINTENANCE INTERVAL CHART
3-1
E
MAINTENANCE INTERVAL CHART
The following chart should be considered strictly as a guide to general maintenance intervals.
Depending on operating conditions, the intervals of maintenance should be changed.
Item Remarks
Initial Every
10 hours
(Break-in)
50 hours
(3 months)
100 hours
(6 months)
200 hours
(1 year)
Refer
page
COWLING:
Water separator drain hole
FUEL SYSTEM:
Fuel line
Fuel filter
CONTROL SYSTEM:
Throttle cables
Remote control throttle cable
Throttle link lever
Remote control shift cable
Shift cable (FT9.9D)
Engine idling speed
Start-in-gear protection device
POWER UNIT:
Engine oil
Oil filter
Timing belt
Valve clearance
Ignition timing
Thermostat
Water leakage
Motor exterior
Exhaust leakage
Cooling water passage
LOWER UNIT:
Gear oil
Impeller
Lower unit leakage
Propeller
GENERAL:
Anode
Battery
Spark plug
Wiring and connector
Bolts and nuts
Lubrication points
Inspect
Inspect
Inspect/replace
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/adjust
Inspect/change
Replace
Inspect/replace
Inspect/adjust
Inspect
Inspect /replace
Inspect
Inspect
Inspect
Inspect/clean
Change
Inspect
Inspect
Inspect
Inspect
Inspect
Cleaning/adjust/
replace
Adjust/reconnect
Tighten
Lubricate
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
3-2
3-2
4-3, 3-2
3-3
3-4
3-5
3-6
3-7
3-8
3-10
3-11
3-11
3-12
3-12
3-14
5-34
—
—
—
—
3-15
6-4, 6-29
3-16
—
3-16
3-17
—
3-18
—
—
3-21
EVERY MONTH