Advanced AF-6600 - AF-5700 Panel Cutout

To Next Page

To Previous Page

Version 16.10 AF-6600 AF-5000 Series Install Manual 24

AF-5700 Panel Cutout

Main Page

Table of Contents5
Introduction10
Installation Planning11
1.1 System Architecture11
1.2 Avionics Power Bus11
1.3 Avionics Data Buses12
1.4 EFIS Display Mounting and Connections15
1.5 System Block Diagram16
Advanced SV-Network Planning20
2.1 SV-Network Wiring to AF-6600 / AF-5000 EFIS Without an ACM20
2.2 SV-Network Wiring to AF-6600 / AF-5000 EFIS with ACM21
2.3 SV-Network Harness Connections21
2.4 SV-Network SV-EMS-220 Harness Connections21
2.5 Advanced SV Network Wiring Table22
Component Locating and Mounting23
3.1 AFS EFIS Mounting and Panel Cutout23
AF-6600 / AF-5600 Panel Cutout23
AF-5700 Panel Cutout24
AF-5800 Panel Cutout25
AF-5500 Panel Cutout25
3.2 Sv-Adahrs-200/20126
3.3 SV-MAG-236 Remote Magnetometer29
ADAHRS-200/201 MAG-236 Magnetic Heading Calibration31
Alarm Output32
Electrical Connections33
EFIS TCW Backup Battery Wiring35
Audio Connections37
Test EFIS Audio Menu37
Master Volume37
External Device Installation38
71410 Sv-Arinc 429 Adaptor38
Advanced-SV Autopilot41
74152 SV-Autopilot Panel46
CO Guardian Display51
74263 Aithre 3.0-S Remote Serial CO Detector52
74262 Aithre 3.0 Remote Analog CO Detector53
11080 Aithre Altus O2 Wiring54
74125 SV-Intercom-2S55
74120 Dynon SV-Com-Radio64
AUDIO Panel PMA450EX / PDA360R76
P/N: 73102 Dynon GPS-250 Antenna Module80
P/N: 73120 Dynon GPS-220 Antenna Module80
Avidyne IFD-440, IFD-540, IFD-550 GPS Navigator81
Garmin G5 EFIS86
Garmin GPS-17588
Garmin GTR-20089
Garmin 430W/530W90
Garmin Gtn650Xi / 750Xi91
Garmin SL-3094
Garmin SL-4094
Garmin GNC-25597
Garmin GTR-22597
Garmin 396/49698
P/N: 74109 Dynon/Afs SV-261 Transponder99
Garmin GTX 327 / GTX 330 Transponder111
Sandia STX 165R Transponder111
P/N: 73140 Wi-Fi Module112
P/N: 74113 SV-ADSB-472 Dual Band Receiver115
Uavionix Echo UAT123
71320 SV-EMS-220 Engine Module124
SV-EMS 220 Sensor and Transducer Wiring125
71321 SV-EMS 221 ROTAX 912Is/915Is Sensor and Transducer Wiring Map129
Physical Mounting133
Engine Sensor Installation134
Lycoming/Continental134
EGT Clamp Installation134
Engine Tachometer (RPM)135
Optional Mag RPM Sensor Installation135
Oil Temperature Sensor Installation137
TIT Probes138
Rotax Engines139
CHT Probes139
EGT Probes140
Rpm140
Rotax Oil Pressure141
Rotax Fuel Pressure143
Diemech Turbine146
Amp Transducer Installation147
Pressure Transducer Installation148
Oil Pressure Transducer Installation148
Fuel Pressure Transducer Installation148
Fuel Flow Transducer Installation150
Fuel Flow Transducer Wiring151
Manifold Pressure Transducer Installation152
Manifold Sensor Connections152
Fuel Tank Level Sensor154
Float Type154
Capacitance Type154
P/N: 51105 Dynon Van's Capacitance Tank Adaptor154
Trim & Flap Position Installation155
Coolant Temp156
Airplane Map Icon Image157
Vendor Logo Splash Screen158
Landing Gear Warning System159
Landing Advisory Mode159
EFIS Setup and Configuration163
Advanced-SV Network Configuration164
SCAN for Network Devices164
Updating Network Components164
Admin Settings Menu165
EFIS RS-232 Serial Ports165
Navigational Source Selection170
Module Configuration171
Display Assignments172
Map Zoom from PFD172
Aircraft Info Menu173
Autopilot Settings174
Autopilot (Roll & Pitch)174
Yaw Damper179
Air Data System181
Altitude181
Airspeed182
Angle of Attack (AOA)184
Outside Air Temp (OAT)185
G-Meter186
Radio & Transponder187
Audio Panel187
Transponder188
COM Radio189
NAV Radio190
Configuring EFIS Engine Gauges191
Electrical System193
Electrical Configuration193
Primary Volts194
Backup Volts195
Volts #2 Input196
Amperage (Shunt)197
Amperage (Hall-Effect)198
Fuel System199
Fuel Flow Gauge199
Fuel Computer199
Fuel Pressure200
Fuel Tank Level Gauges201
Engine Sensors206
Manifold Air Pressure206
Prop RPM207
Oil Pressure208
Oil Temperature209
Exhaust Gas Temp (EGT)210
Cylinder Head Temp (CHT)211
Turbo Inlet Temp (TIT)212
Horsepower213
Carb Temp214
Coolant Temp215
Flap Position216
Elevator Trim217
Aileron Trim220
Cabin Environmental221
CO Detector221
O2 Tank Pressure221
Pulse Oximeter221
Test Audio222
Switch Inputs223
APPENDIX A: Specifications224
Physical224
Power Requirements224
Temperature Specifications225
APPENDIX B: Electrical Connections226
Advanced SV Network Wiring227
P/N: 53625 EFIS Expansion Network Harness229
APPENDIX C: Metric Units230
APPENDIX D: System Data Backups232
Restoring System Data from a USB Memory Stick Backup234
APPENDIX E: AF-6600 / AF-5000 Software Updates235
APPENDIX F: Database Updates239
Seattle Avionics Dynon Skyview Chart Data239
Map Nav Data239
Loading AFS Provided USA Map/Nav Data240
Worldwide Jeppesen Data Files243
Pocket FMS Map Data Files246
APPENDIX J: Troubleshooting249
APPENDIX K: Vertical Power VP-X Interface250
Electrical System Status Page250
VPX Interface Configuration251
APPENDIX M: Upgrading an AF-3000/4000 to an AF-6600253
Moving AF-ARINC from AF-4500 Serial Port #4 DSUB-9 to AF-5000 DSUB 15 Pin aux255
Upgrading from Internal AFS Internal Engine Monitor Board to Dynon SV-EMS-220256
APPENDIX P: Performing Pitot/Static Checks257
APPENDIX Q: Verifying ADS-B Output Data260
AF-6600 / AF-5000 ARINC Output261
AF-6600 FADC1 RS-232 Data261
APPENDIX W: Harness Wiring Diagrams262
P/N: 53600 EFIS Main Harness263
P/N:538XX CHT/EGT Harnesss264
AF-6600 / AF-5000 Series Post Installation Check265
Registration Information267

Advanced AF-6600 - AF-5700 Panel Cutout

Table of Contents