Chery A1 2009 User Manual

ELECTRONIC ENGINE CONTROLS
03
CONTENTS
page
1.3L Engine Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 03-1
Engine Symptom Diagnosis . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 03-178
Ignition Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 03-200
Evaporative Emissions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 03-207
1.3L ENGINE CONTROLS
GENERAL INFORMATION
03-3
Description 03-3
Operation 03-3
Electronic Engine Control Input & Output
Device Failure Modes 03-4
Specifications 03-5
Special Tools 03-6
Electrical Schematics 03-9
Engine Control Module (ECM) Connector
Pin-Out Table 03-20
DIAGNOSIS & TESTING
03-21
Diagnostic Help 03-21
Intermittent DTC Troubleshooting 03-21
Ground Inspection 03-21
Electronic Throttle Control Actuator
Self-Learning Procedure Introduction 03-21
Diagnostic Trouble Code (DTC) List 03-22
Power Supply and Ground Circuit Test 03-26
Power Supply and Ground Circuit 03-26
Diagnostic Trouble Code (DTC) Tests 03-33
P0016 - Camshaft Position-Crankshaft
Position Correlation Error 03-33
P0031 - O
2
Sensor 1 Heater Control
Circuit Low, P0032 - O
2
Sensor 1
Heater Control Circuit High 03-42
P0105 - Manifold Absolute Pressure/
Barometric Pressure Circuit, P0106 -
Manifold Absolute Pressure Or
Barometric Pressure Range/
Performance 03-47
P0107 - Manifold Absolute Pressure Or
Barometric Pressure Low Input, P0108
- Manifold Absolute Pressure Or
Barometric Pressure High Input 03-52
P0112 - Intake Air Temperature Circuit
Low Input 03-57
P0113 - Intake Air Temperature Circuit
High Input 03-61
P0117 - Engine Coolant Temperature
Circuit Low Input 03-65
P0118 - Engine Coolant Temperature
Circuit High Input 03-70
P0122 - Throttle Position Sensor A
Circuit Low Input, P0123 - Throttle
Position Sensor A Circuit High Input 03-75
P0132 - O
2
Sensor Circuit 1 High
Voltage 03-81
P0171 - Fuel Trim System Too Lean 03-86
P0172 - Fuel Trim System Too Rich 03-96
P0201 - Cylinder 1 - Injector Circuit,
P0202 - Cylinder 2 - Injector Circuit,
P0203 - Cylinder 3 - Injector Circuit,
P0204 - Cylinder 4 - Injector Circuit 03-105
P0221 - Throttle Position Sensor B
Performance 03-111
P0321 - Distributor Engine Speed
In-Phase Circuit Performance 03-119
P0324 - Knock Control System Error,
P0327 - Knock Sensor 1 Circuit Low
Input, P0328 - Knock Sensor 1 Circuit
High Input 03-124
P0340 - Camshaft Position Sensor
Circuit, P0341 - Camshaft Position
Sensor Performance, P0342 - Camshaft
Position Sensor Circuit Low Input,
P0343 - Camshaft Position Sensor
Circuit High Input 03-129
P0444 - Evaporative Emission System
Purge Control Valve Circuit Open 03-135
P0506 - Idle Control System RPM
Lower Than Expected 03-140
03
03–1
Chery Automobile Co., Ltd.

Chery A1 2009 Specifications

General

Brand	Chery
Model	A1 2009
Category	Automobile
Language	English