4.2
ELECTRONIC FUEL INJECTION
9924125 - 2013 RANGER RZR / RZR S / RZR 4 Service Manual
© Copyright 2012 Polaris Sales Inc.
GENERAL INFORMATION
Special Tools
SPX Corp: 1-800-328-6657 or http://polaris.spx.com/
Throttle Position Sensor (TPS) Tester - 2201519-A
This tester allows the use of a
digital multi-meter to test
TPS function as well as perform the TPS adjustment
procedure.
TPS Tester Wire Harness - PU-47466
This TPS wire harness is part of 2201519-A and
incor
porates two TPS connectors to allow for multi-use
applications.
NOTE: Voltage Regulator (547927) is required if
using T
PS Tester Wire Harness (PU-47466). You may
already have this regulator (marked 4010264) as part
of another TPS Tester Kit. If you do not have this
regulator, you must order one from SPX at 1-800-
328-6657.
* Gasoline is extremely flammable and explosive
under certain conditions.
* EFI components are under high pressure.
Verify system pressure has been
relieved before disassembly.
* Never drain the fuel system when the engine is hot.
Severe burns may result.
* Do not overfill the tank. The tank is at full capacity
when the fuel reaches the bottom of the filler neck.
Leave room for expansion of fuel.
* Never start the engine or let it run in an enclosed area.
Gasoline powered engine exhaust fumes are
poisonous and can cause loss of consciousness
and death in a short time.
* Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
ga so li ne is st or ed .
* If you get gasoline in your eyes or if you should
swallow gasoline, seek medical attention immediately.
* If you spill gasoline on your skin or clothing,
immediately wash with soap and water
and change clothing.
* Always stop the engine and refuel outdoors
or in a well ventilated area.
PART
NUMBER
TOOL DESCRIPTION
2201519-A Throttle Position Sensor (TPS) Tester
PU-47466 TPS Tester Wire Harness
547927 TPS Tester Regulator
PU-43506-A Fuel Pressure Gauge Kit
PV-48656 Fuel Pressure Gauge Adaptor
PU-47063-B
Digital Wrench™ Diagnostic Software
(Incl
udes most recent version of software w/
serial number, standard interface cable, USB-
Serial Adaptor cable and SmartLink Module Kit)
PU-47471
Digital Wrench™ SmartLink Module Kit
(PU
-47470, PU-47469, PU-47468)
PU-47470
Digital Wrench™
PC Interface Cable
PU-47469
Digital Wrench™
V
ehicle Interface Cable
PU-47468
Digital Wrench™
SmartLink Module
To Next Page
Loading...
