Start-up - Inspections before daily start-up
4 - 7
830 / 07.2012 Original operating instructions
S5 Is the undercarriage (e.g. tires, axles, drive
shafts/universal joints) undamaged?
If necessary, repair or replace
S6 Are the wheel nuts tight and the intermediate
rings firmly seated?
If necessary, retighten to the specified torque
S7 Is the tire pressure correct? (For pneumatic
tires)
If necessary, repair leaks and pump up tires
(using a tire cage)
S8 Is the hydraulic system (lines, hoses etc.) free
of leaks and undamaged?
If necessary, tighten connections or replace
seals
S9
Are the hydraulic cylinders (e.g. outrigger,
stick, floating axle cylinders, steering cylinders)
free of leaks and undamaged? Do the piston
rods show any damage (cracking etc)?
If necessary, tighten connections or replace
seals
S10 Is the gate on the hydraulic tank open? If necessary, open
S11 Are the fluid reservoirs sufficiently full
(refrigerant, grease, diesel, hydraulic oil,
engine oil, fuel, windshield cleaning water,
pivoting gear, etc.)?
If necessary, repair leaks and add fluids.
Follow manufacturer's instructions!
S12 Are TopAir and air filter cartridges damaged
or contaminated?
If necessary, clean or replace
S13 Is the fan wheel undamaged? If necessary, replace
S14 Are the cooling fins on the combination cooler
soiled or damaged?
If necessary, clean by reversing the fan or
replace.
S15 Is the cooling system (cooler, hoses,
tubing etc.) free of leaks?
If necessary, repair leaks and add refrigerant.
Follow manufacturer's instructions! Replace
defective components.
S16 Are all hose clips tight and the hose
connections free of leaks?
If necessary, retighten or replace
S17 Has the water separator on the fuel system
been drained?
If necessary, drain
S18 Are the V-belts undamaged and tensioned? If necessary, tension again or replace
S19 Are the electrical lines damaged? If necessary, repair or replace
S20 Are the cable connections (poles) of the
battery corroded?
If necessary, clean and grease; cover
terminals with protective caps.
S21 Are the batteries held in place securely? If necessary, retighten holders
S22 Are all service access doors closed? If necessary, close
No.
Visual checks Steps to take
To Next Page
Loading...