CUMMINS N14 - Engine Cranks But Will Not Start (No Smoke From Exhaust)

Engine Cranks But Will Not Start (No Smoke From Exhaust)
Cause Corrections
----------
Fuel Level in Tank Too Low
OK
f
Add fuel.
----------
Starting Motor Rotation Incorrect
OK
f
Check direction of crankshaft rotation (N14
is right hand rotation). Replace starting
motor, if necessary. Refer to Procedure
6-06.
----------
Shutoff Valve Closed
OK
f
Use manual override (STC only). Refer to
Procedure 5-04. Replace or repair electric
problem. On CELECT™ refer to the N14
CELECT™ System Troubleshooting and
Repair Manual, Bulletin No. 3810469.
----------
Auxiliary Shutdown Device (Skinner
Valve) Closed. External Governor Mal-
functioning or Installed Incorrectly
OK
f
Repair or replace. Refer to the manu-
facturer’s instructions.
----------
On CELECT™ Engines, Electrical
Power to ECM Interrupted
OK
f
Refer to the N14 CELECT™ System
Troubleshooting and Repair Manual,
Bulletin No. 3810469.
----------
Fuel Filter Plugged or Suction Line
Broken or Restricted
OK
f
Replace fuel filter and/or replace suction line.
----------
Fuel Connection Loose on Suction
Side of Pump
OK
f
Tighten all fuel fittings and connections
from fuel tank to fuel pump.
(Continued)
SectionT-Troubleshooting Troubleshooting Symptoms Charts
N14 Page T-29