10.36
9929419 R02 - 2018-2019 RZR XP / XP 4 Turbo S Service Manual
© Copyright Polaris Industries Inc.
EFI DIAGNOSTICS
FUEL SYSTEM TROUBLESHOOTING
Fuel Starvation / Lean Mixture
Symptoms: Hard start or no start, bog, backfire, popping
through intake / exhaust, hesitation, detonation, low
power, spark plug erosion, engine runs hot, surging, high
idle, idle speed erratic.
• No fuel in tank
• Restricted tank vent, or routed improperly
• Fuel lines or fuel injectors restricted
• Fuel filter plugged
• Fuel pump inoperative
• Air leak in system
• Intake air leak (throttle shaft, intake ducts, air box
cover)
• Incorrect fuel pressure signal
• EVAP system leak/blockage
Rich Mixture
Symptoms: Fouls spark plugs, black, sooty exhaust
smoke, rough idle, poor fuel economy, engine runs
rough/ misses, poor performance, bog, engine loads up,
backfire.
• Air intake restricted (inspect intake duct)
• Air filter dirty/plugged
• Poor fuel quality (old fuel)
• Fouled spark plug
• Injector failure
• Faulty fuel pump/regulator
• Incorrect fuel pressure signal
Idle Too High (if > 1400 RPM when warm)
• Faulty electrical connection
Idle Too Low (if < 1100 RPM when warm)
• Plugged air filter
• Leaking injector (rich condition)
• Belt dragging
• Throttle stop screw tampering
Erratic Idle
• Air Leaks, dirty injector
• TMAP damaged (check with Digital Wrench®)
• Tight valves (low compression or high leakdown)
• Ignition timing incorrect
• Belt dragging
• Dirty air filter
• High percentage of cylinder leakdown (worn engine)
• Low compression (worn engine)
• Spark plug(s) fouled
• Spark plug wires loose or worn
• Faulty electrical connection
DIAGNOSTIC
To Next Page
Loading...
Need help?
General
