Belarus 82.3 - Page 158

82.3-0000010 OM
158
Table 5.3.1 finished
Operation
No
Operation description
Periodicity, h
8-10
125
250
500
1000
2000
57
Check the fuel pump on the stand
X
58
Check injectors for injection starting pressure
and fuel spray quality
X
59
Check fuel injection advance angle
X
60
Replace air conditioning filter drier
Every 800 hours of operation,
but at least once a year
61 Adjust oil pressure in engine lubrication system
As engine oil pressure deviates
from the norm
62
Replace transmission hydraulic filter cartridge
When contaminated
63
Adjust transmission hydraulics pressure setting
valve
As oil pressure in transmission
hydraulic system deviates from
the norm
64
12)
Service engine air cleaner
When contaminated
________________________________________________________________________________________________________________________________________________
1)
The operation is carried out once with the first STM (after 8-
10 hours of operation)
performed by the consumer and then every 125 hours of tractor operation.
2
) When using the tractor in difficult operating conditions and in a large dustiness, the
operation must be performed every 10 hours of work, i.e. every shift.
3)
The operation is carried out
when the tractor RLL is equipped with lower links with
grippers.
4)
Monitoring and, if necessary, adjusting the internal pressure in tractor tires, is per-
formed each time the tractor is moved f
rom one type of work to another and the machines
and implements attached to it are changed.
5)
When the tractor is working in very dusty conditions, the operation must be per-
formed every 20 hours of tractor work.
6)
The frequency of checking and servicing the battery is at least once every 3 months.
7)
When using grease MS-1000 TU 0254-003-45540231-
99, the operation should be
performed at a lower frequency, according to table 5.8.1
8)
The first and second replacements are carried out after 500 hours of tractor opera-
tion. Further replacement is required every 1000 hours of operation, simultaneously with the
oil change.
9)
When working in conditions of increased dustiness, flush the filter cartridge of the hy-
draulic system breather after 250 hours of tractor operation.
10)
At the same time as changing the oil in the transmission, it is necessary to replace
the replaceable filter cartridge of the transmission hydraulic system, regardless of the timing
of its previous replacement.
11)
When installing screw-type lifting rods on order, this operation is not performed.
12)
Service the engine air cleaner when the alarm indicator of air cleaner filter dirtiness
located on the dashboard lights up, but not less than after 1000 hours of tractor operation.