82.3-0000010 OM
84
3.3 Safety measures to be taken when operating the tractor
3.3.1 General safety measures to be taken when operating the tractor
The cab complies with category 2 under EN 15695-1:2009. Cab of this category en-
sures protection against dust, but not against sprays and vapor – the tractor shall not be
used under conditions, requiring protection against sprays and vapor.
The tractor cab corresponds to Level I of Falling-Object Protective Structures
(FOPS) under GOST R ISO 3449-2009.
Do not operate the tractor in a closed room without proper ventilation. Exhaust gas
may be lethal.
Tractor start-up and operation with the tractor facing removed or exposed is not al-
lowed.
It is forbidden to expose the tractor facing when the engine is running.
Do not start the engine when staying outside the operator's seat. When starting the
engine and manipulating the controls, always stay inside the cab in the operator's seat.
Do not start the engine by way of towing.
Before starting the engine, engage the parking brake, the rear PTO shall be disen-
gaged, the gear shifting lever shall be in the “Neutral” position.
During tractor start-up, there shall be no people under, in front of or behind the trac-
tor, as well as between the tractor and the coupled implement or trailer.
Before setting on the move, warn people around including those operating the coupled
implements by using the horn, make sure the parking brake is off and start moving slowly.
Use safety harnesses (supplied against order) at transport operations.
During tractor operation, no passengers are allowed to stay in the cab (a passenger
may stay in the cab only in case an additional seat is installed and only during transport
operations).
Do not leave the tractor on the move.
When performing transport operations, observe traffic regulations adopted in the
country, where the tractor is operated.
Transport work can be performed by operators who have passed an examination on
the traffic regulation.
Drive the tractor on slippery roads with automatic DL (if mounted) engaged only at a
speed not higher than 10 km/h.
When using the tractor for transport operations, do the following:
- set a track of (1530±20) mm for front wheels and (1800±20) mm for rear wheels.
- check operation of brakes; interlock brake pedals, check and if necessary adjust
the brakes for simultaneous operation;
- check operation of the parking brake;
- check condition of devices for light and sound annunciation; hauling trailers shall
have rigid hitches and be linked with a safety chain or a cable;
- never move downhill with the gear disengaged. Move uphill and downhill at the
same gear;
It is forbidden to operate with a trailer without independent brakes if its weight ex-
ceeds a half of the total actual weight of the tractor. The faster you move and the more
weight you tow, the bigger the safety distance shall be.
It is forbidden to drive the tractor with twinned wheels on public roads!
Hauling people inside trailers is forbidden.
Before getting down to work with a trailer, turn the compressor on, check the condi-
tion of the trailer brake pneumatic drive and air pressure in the system. Eliminate the fail-
ures detected. Make sure to connect the trailer brake pneumatic drive. Carry out connec-
tion of the trailer connecting head to the tractor connecting head with the parking brake
engaged.
To Next Page
Loading...
