Belarus 82.3 - Page 7

82.3-0000010 OM
7
5.4.5 Maintenance service every 1000 hours of operation (MS-3) ................................... 187
5.4.6 Maintenance service every 2000 hours of operation............................................... 197
5.4.7 Maintenance that does not coincide with the timing of MS-1, 2MS-1, MS-2, MS-3
and special MS ................................................................................................................ 198
5.4.8 General maintenance services ............................................................................... 199
5.5 Seasonal maintenance services .......................................................................................... 203
5.6 Safety measures during maintenance and repair operations ..................................... 204
5.6.1 General safety requirements ................................................................................... 204
5.6.2 Safety precautions for exclusion of hazardous situations related to accumulator
battery and fuel tank. ....................................................................................................... 204
5.6.3 Guidelines for safe use of leveling jacks and places where they shall be installed ... 205
5.7 Tools, fixtures and measuring devices for maintenance service and repair ............... 206
5.8 Filling and lubrication of the tractor with fuel and lubrication materials ............................. 207
6. POSSIBLE MALFUNCTIONS AND GUIDELINES FOR TROUBLESHOOTING............... 212
6.1 Possible clutch failures and instructions for troubleshooting ...................................... 212
6.2 Possible failures in gearbox and instructions for troubleshooting .............................. 214
6.3 Possible failures in the electronic control system for rear axle differential lock, front driving
axle drive, rear power take off shaft and instructions for troubleshooting ............................... 215
6.4 Possible failures in rear power take-off shaft and instructions for troubleshooting ..... 217
6.5 Possible failures in rear axle and instructions for troubleshooting ............................. 218
6.6 Possible failures of brakes and instructions for troubleshooting ................................ 219
6.7 Possible failures in the pneumatic system and instructions for troubleshooting ......... 220
6.8 Possible failures of front driving axle, tires and instructions for troubleshooting ........ 222
6.8.1 Possible failures of FDA and instructions for troubleshooting ................................. 222
6.8.2 Possible failures of tires and instructions for prevention and troubleshooting ......... 224
6.9 Possible failures of the hydrostatic steering control and instructions for
troubleshooting ................................................................................................................ 226
6.10 Possible failures of hydraulic lift linkage and instructions for troubleshooting .................. 229
6.10.1 Possible failures of HLL with draft control unit and instructions for troubleshooting ... 229
6.10.2 Possible failures of HLL without draft control unit and instructions for
troubleshooting ................................................................................................................ 232
6.11 Possible failures in transmission hydraulic system and instructions for
troubleshooting ................................................................................................................ 233
6.12 Possible failures in the electrical equipment and instructions for troubleshooting .... 234
6.13 Possible failures of air-ventilation, cab heating and air conditioning system and
instructions for troubleshooting ........................................................................................ 236
6.14 Possible engine failures and instructions for troubleshooting .................................. 238
7 TRACTOR STORAGE .................................................................................................. 241
7.1 General instructions ................................................................................................... 241
7.2 Requirements for inter-shift tractor storage ................................................................ 241
7.3 Requirements for short-term tractor storage .............................................................. 241
7.4 Requirements for long-term tractor storage outdoors ................................................ 242