Section 01 MAINTENANCE
Subsection 01 (MAINTENANCE SCHEDULE)
MAINTENANCE SCHEDULE
Maintenance is very i mportant for keeping your vehicle in safe operating condition.
Proper maintenance is the owner’s responsibility. A warranty claim may be denied if, among other things,
the owner or operator caused the problem through improper maintenance or use.
Perform periodic checks and follow the maintenance schedule. The maintenance schedule does not
exempt the pre-ride inspection.
Verifying fault codes, as first maintenance step, is a good practice and is highly recommended.
WARNING
Failure to properly maintain the vehicle according to the maintenance schedule and procedures
can make it unsafe to operate.
EPA Regulation - Canadian and USA Vehicles
A repair shop or person of the owner's choosing may maintain, replace, or repair emission control
devices and systems. These instructions do not require components or service by BRP or authorized
Sea-Doo dealers.
Although an
authorized Sea-Doo dealer has an in-depth technical knowledge and tools to service your
vehicle, th
e emission-related warranty is not conditioned on the use of an authorized Sea-Doo dealer or
any other es
tablishment with which BRP has a commercial relationship.
Proper maintenance is the owner’s responsibility. A warranty claim may be denied if, among other things,
the owner or operator caused the problem through improper maintenance or use.
You must follow the instructions for fuel requirements in the fueling section of the Operators Guide. Even
if gasoline containing greater than ten volume percent ethanol is readily available, the US EPA issued a
prohibition against the use of gasoline containing greater than 10 vol% ethanol that applies to this vehicle.
The use of gasoline containing greater than 10 vol% ethanol with this engine may harm the emission
control system.
The mainte
nance schedule does not exempt the pre-ride inspection. Refer to the
OPERATORS GUIDE
.
AFTER EACH RIDE IN SALT OR DIRTY WATER
Rinse engine compartment with fresh water and drain salt water.
Flush exhaust system
EVERY MONTH IN SALT OR DIRTY WATER
Spray ant
icorrosion lubricant to metallic components in engine compartment (every 10 h o urs in salt water use)
Inspect sacrificial anodes
AFTER FIRST 6 MONTHS OR 50 HOURS (WITCH EVER COMES FIRST)
Replace engine oil and filter (1630 ACE engines)
EVERY YEAR AT PRESEASON OR 100 HOURS OF OPERATION
(WHICHE
VER COMES FIRST)
Inspect sacrificial anodes
Check for fault codes
Perform
all items indicated in the Pre-Ride Inspection and Post Operation Care
Replace engine oil and filter
Inspect engine rubber mounts
Inspec
t the cooling system (coolant level, hoses and fasteners for leaks)
219100963-002 5
To Next Page
Loading...
Need help?
General
