Ski-Doo REV Series Shop Manual

Section 03 TROUBLESHOOTING
Subsection 05 (SUSPENSION AND TRACK)
SUSPENSION AND TRACK
The following chart is provided to help diagnose the probable source of troubles. It should be used as a
guideline. Some causes or corrections may not apply to a specific model.
SYMPTOM SUSPENSION IS TOO LOW.
CONDITION NORMAL USE
1. Check condition of springs.
a. Springs are weakened or broken.
Replace springs.
2. Check springs preload.
a. Low spring preload.
Increase preload to the recommended position.
TEST/INSPECTION
3. Check springs.
a. Installed springs are too soft.
Install optional stiffer springs, refer to service bulletin SPRING REFERENCE ACCORDING TO LOAD.
SYMPTOM REAR SUSPENSION BOTTOMS OUT.
CONDITION NORMAL USE
1. Check condition of springs.
a. Springs are weakened or broken.
Replace springs.
2. Check springs preload.
a. Low spring preload.
Increase preload to the recommended position.
3. Check springs.
a. Springs installed are too soft.
Install optional stiffer springs, refer to service bulletin SPRING REFERENCE ACCORDING TO LOAD.
4. Check the rear shock motion ratio position.
a. It is adjusted in soft position.
Adjust rear shock motion ratio to firm position.
TEST/INSPECTION
5. Check condition of the rear shock absorber.
a. Damaged rear shock absorber.
Replace rear shock absorber.
mmr2004-Rev 73

Ski-Doo REV Series Specifications

General

Chassis	REV
Track Width	15 in
Fuel Capacity	10.6 gal
Seating Capacity	1
Reverse	Available on most models
Electric Start	Available on most models