Ski-Doo REV Series Shop Manual

Section 01 TOOLS AND SERVICE PRODUCTS
Subsection 02 (SERVICE PRODUCTS)
High strength threadlocker
(P/N 293 800 005)
Loctite
®
271:
Threadlocker (10 mL) (red, high
strength)
APPLICATION
Fasteners and studs up to 25
mm (1 in) diameter.
Sealing compound
(P/N 420 297 906)
(30 mL)
APPLICATION
To seal crankcase on all ZX series
engines.
NOTE: This product replaces the
larger tube (P/N 420 297 905).
Paste gasket
(P/N 413 702 700)
Loctite
®
515:
Gasket eliminator (50 mL)
APPLICATION
Crankcase halves and gearbox
mating surfaces.
Paste gasket
(P/N 293 800 038)
Loctite
®
518:
Gasket eliminator (50 mL)
APPLICATION
Crankcase halves and gearbox
mating surfaces.
Loctite
®
primer
(P/N 293 800 041)
PrimerN128g(5oz)
APPLICATION
To prepare mating surfaces be-
fore applying paste gasket, re-
taining compound or threadlock-
ers.
NOTE: Only the P/N has been
changed. This product is identi-
cal to the P/N 413 708 100.
Gasket/paint remover
(P/N 413 708 500)
Loctite
®
Chisel 510 g (18 oz)
APPLICATION
Clean mating surfaces of cylin-
ders and crankcase. Remove
carbonincombustioncham-
bers.
Molykote PG 54
(P/N 420 899 763)
(10 g)
APPLICATION
To lubricate pawl and pawl lock
of rewind starter.
Molykote G-n paste
(P/N 711 297 433)
(50 g)
APPLICATION
To lubricate RAVE valve stem
on engine with oil seal in RAVE
housing.
22 mmr2004-Rev

Ski-Doo REV Series Specifications

General

Chassis	REV
Track Width	15 in
Fuel Capacity	10.6 gal
Seating Capacity	1
Reverse	Available on most models
Electric Start	Available on most models