Ski-Doo REV Series Shop Manual

Section02MAINTENANCE
Subsection 01 (MAINTENANCE CHART)
I: Inspect, verify, clean, adjust,
lubricate or replace if necessary
C: Clean
L: Lubricate
R: Replace
A: Adjust
10 h
or
500 km
(300 m.)
(1)
Weekly
or
240 km
(150 m.)
Monthly
or
800 km
(500 m.)
Once
a year
or
3200 km
(2000 m.)
6000 km
(3700 m.)
Storage
(1)
Preseason
preparation
(1)
Refer to the
following
subsection(s)
ELECTRICAL
EMS Fault Codes
(4)
I I
05-03
Spark Plugs
(3) (4)
I I R
05-02 and 07-02
Battery (if so equipped)
I I I I
05-02 and 07-03
Headlamp Beam Aiming
A A
10-01
Wiring Harnesses, Cables and Lines
(4)
I I I
10-01
Operation of Lighting System (HI/LO
beam, brake light, etc.) Test Operation
of Engine Cut-Out Switch and Tether
Cut-Out Switch
I I I
Operator’s Guide
VEHICLE
Rags in Air Intake and Exhaust System
R C
02-02 and 02-03
Engine Compartment
C C C
02-02
Vehicle Cleaning and Protection
C C C
02-02
(1) To be performed by an authorized Ski-Doo dealer.
(2) Lubricate whenever the vehicle is used in wet conditions (wet snow, rain, puddles).
(3) Before installing new spark plugs at preseason preparation, it is suggested to burn excess storage oil by starting the engine
with the old spark plugs. Only perform this operation in a well-ventilated area.
(4) Emission-related
mmr2004-Rev 31

Ski-Doo REV Series Specifications

General

Chassis	REV
Track Width	15 in
Fuel Capacity	10.6 gal
Seating Capacity	1
Reverse	Available on most models
Electric Start	Available on most models