1-iv Table of Contents
Starter Motor Disassembly and Assembly ........... 1I-4
Starter Motor Related Parts Inspection ................ 1I-6
Starter Relay Removal and Installation................ 1I-6
Starter Relay Inspection....................................... 1I-7
Turn Signal / Side-stand Relay Removal and
Installation.......................................................... 1I-8
Side-stand / Ignition Interlock System Parts
Inspection........................................................... 1I-8
Starter Clutch Removal and Installation............. 1I-10
Starter Clutch Inspection.................................... 1I-12
Starter Button Inspection.................................... 1I-12
Specifications...................................................... 1I-13
Service Data....................................................... 1I-13
Tightening Torque Specifications....................... 1I-13
Special Tools and Equipment ............................ 1I-14
Recommended Service Material ........................ 1I-14
Special Tool ....................................................... 1I-14
Charging System......................................1J-1
Schematic and Routing Diagram........................ 1J-1
Charging System Diagram .................................. 1J-1
Component Location ........................................... 1J-1
Charging System Components Location............. 1J-1
Diagnostic Information and Procedures............ 1J-1
Charging System Symptom Diagnosis................ 1J-1
Battery Runs Down Quickly ................................ 1J-2
Repair Instructions .............................................. 1J-3
Battery Current Leakage Inspection.................... 1J-3
Regulated Voltage Inspection ............................. 1J-3
Generator Inspection........................................... 1J-4
Generator Removal and Installation.................... 1J-4
Regulator / Rectifier Construction ....................... 1J-8
Regulator / Rectifier Inspection ........................... 1J-8
Regulator / Rectifier Removal and Installation .... 1J-9
Battery Components ......................................... 1J-10
Battery Charging ............................................... 1J-10
Battery Removal and Installation ...................... 1J-12
Battery Visual Inspection................................... 1J-13
Specifications..................................................... 1J-13
Service Data...................................................... 1J-13
Tightening Torque Specifications...................... 1J-13
Special Tools and Equipment ........................... 1J-14
Recommended Service Material ....................... 1J-14
Special Tool ...................................................... 1J-14
Exhaust System....................................... 1K-1
Precautions...........................................................1K-1
Precautions for Exhaust System .........................1K-1
Diagnostic Information and Procedures............1K-1
Engine Symptom Diagnosis ................................1K-1
Repair Instructions ..............................................1K-2
Exhaust System Construction .............................1K-2
Exhaust Pipe / Muffler Removal and
Installation .........................................................1K-3
Exhaust System Inspection.................................1K-7
Specifications.......................................................1K-8
Tightening Torque Specifications........................1K-8
Special Tools and Equipment .............................1K-8
Recommended Service Material .........................1K-8
To Next Page
Loading...
