Monaco Executive 2005 - Lubrication Charts; Cummins - ISM

Chassis Information --- Section 10
The Executive 2005
513
When:
Before Each Trip + Daily Enroute
At Oil Change
Refer to OEM Manual
Refer to OEM Manual
Monthly
15,000 or Annually
15,000 or 6 Months
Refer to OEM Manual
2 -3 Years
Weekly
Refer to OEM Manual
30,000 or Annually
250,000 or 3 Years
10,000 or 3 Months
10,000 or Annually
10,000 or Annually
5,000 or 6 Months
5,000 or 6 Months
5,000 or 6 Months
30,000 or Annually
Monthly
6,000 or 3 Months
6,000 or 3 Months
Before Each Trip + Daily Enroute
Twice a Year
Refer to OEM Manual
Bi-Monthly
10,000 or Quarterly
LUBRICATION CHARTS -
Cummins - ISM
070173m
Component:
Engine Oil
Engine Oil Filter
Transmission
Engine Coolant
Hydraulic Fluid Reservoir
Hydraulic Filter
Filter Fuel/Water Separator (Primary)
Filter Fuel (Secondary)
Air Dryer Filter
Radiator/Charge Air Cooler
Coolant Filter
Wheel Bearings
Rear Differential
Slack Adjusters/S-Cams
Drive Shaft Universal Joints
Drive Shaft Slip Yoke
Drag Link
Center Link
Spindles/Kingpins
Steering Drive Shaft
Air Tank Drains
HWH Reservoir
RVA Reservoir
Tire Pressure
Steering Box
Generator
Batteries
1.
2.
3.
4.
5.
6.
7a.
7b.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
20.
21.
22.
23.
24.
25.
26.
Action:
Keep to Full Mark
Replace
Keep to Full Mark
Replace
Keep to Full Mark
Replace
Replace
Replace
Replace
Inspect
Replace
Re-pack
To Filler Plug
Grease-3 Fittings ea.
Grease-2 Fittings
Grease-1 Fitting
Grease-2 Fitting
Grease-2 Fittings
Grease-2 Fittings ea.
Grease-3 Fittings
Drains
Keep to Full Mark
Keep to Full Mark
Check
Grease-1 Fitting
Refer to Service Manual
Inspect
Apply
Code-Refer to Chart:
EO
OEM
TS
AF
TF
TF
FF
OEM
-
-
OEM
HT
MP
CBL
CL
CL
CL
CL
CL
CL-4
-
TF
TF
-
CL
OEM
DW
P
FRONT