3-13
PERIODIC MAINTENANCE
• Replace the air filter element every 20000 km
(12000 mi) of operation.
• The air filter needs more frequent service if you
are riding in unusually wet or dusty areas.
6. Install:
• Air filter case cover
ECA20710
Never operate the engine without the air filter
element installed. Unfiltered air will cause
rapid wear of engine parts and may damage
the engine. Operating the engine without the
air filter element will also affect throttle body
synchronization, leading to poor engine per-
formance and possible overheating.
When installing the air filter element into the air
filter case cover, make sure that the sealing sur-
faces are aligned to prevent any air leaks.
7. Install:
• Center cover
Refer to “GENERAL CHASSIS (2)” on
page 4-11.
8. Install:
• Radiator cover
• Side panel
• Bottom side cowling
Refer to “GENERAL CHASSIS (1)” on
page 4-1.
EAS31181
CLEANING THE V-BELT CASE AIR FILTER
ELEMENT
1. Remove:
• Bottom side cowling
• Side panel
• Bottom center cowling
Refer to “GENERAL CHASSIS (1)” on
page 4-1.
• Center cover
• Fuel tank cover assembly
• Side cover
• Rear side cowling assembly
• Footboard
Refer to “GENERAL CHASSIS (2)” on
page 4-11.
2. Remove:
• V-belt case air filter element (left)
Refer to “WATER PUMP” on page 6-11.
3. Remove:
• V-belt case air filter case cover
• V-belt case air filter case
• V-belt case air filter element (right)
Refer to “V-BELT AUTOMATIC TRANSMIS-
SION” on page 5-39.
4. Clean:
• V-belt case air filter element
Blow the compressed air to the inner surface
of the V-belt case air filter element.
5. Check:
• V-belt case air filter element
Damage Replace.
NOTICE
ECA13441
Since the V-belt case air filter element is a
dry type, do not let grease or water contact it.
6. Install:
• V-belt case air filter element (right)
• V-belt case air filter case
• V-belt case air filter case cover
7. Install:
• V-belt case air filter element (left)
V-belt case air filter case screw
7 N·m (0.7 kgf·m, 5.2 lb·ft)
V-belt case air filter case cover
screw
7 N·m (0.7 kgf·m, 5.2 lb·ft)
To Next Page
Loading...
Need help?
General
