Yamaha TMAX TECH MAX 2020 - Page 94

3-2
PERIODIC MAINTENANCE
6 * Rear brake
• Check operation, fluid level,
and for fluid leakage.
• Replace brake pads if neces-
sary.

7 * Brake hoses
• Check for cracks or damage. 
• Replace. Every 4 years
8 * Brake fluid • Change. Every 2 years
9
Rear brake lock
cable
• Check cable length.
• Adjust if necessary.
At the initial interval and 4000 km (2400 mi) after the initial 1000 km
(600 mi) and every 5000 km (3000 mi) thereafter.
10 * Rear brake lock
• Check operation.
• Adjust.

11 * Wheels
• Check runout and for damage.
• Replace if necessary.

12 * Tires
• Check tread depth and for
damage.
• Replace if necessary.
• Check air pressure.
• Correct if necessary.

13 * Wheel bearings
• Check bearing for looseness
or damage.

14 * Drive belt
• Check belt condition.
• Replace if damaged.
• Check belt tension.
• Adjust if necessary.
At the initial interval and every 10000 km (6000 mi) until 40000 km
(24000 mi), and every 5000 km (3000 mi) thereafter.
15 *
Drive pulley and
drive axle
•Lubricate. 
16 * Steering bearings
• Check bearing assemblies for
looseness.
 
• Moderately repack with lithi-
um-soap-based grease.

17 * Chassis fasteners
• Make sure that all nuts, bolts
and screws are properly tight-
ened.

18
Front and rear
brake lever pivot
shaft
• Lubricate with silicone grease. 
19 *
Sidestand, center-
stand
• Check operation.
• Lubricate with lithium-soap-
based grease.

20 * Sidestand switch
• Check operation and replace
if necessary.

21 * Front fork
• Check operation and for oil
leakage.
• Replace if necessary.

22 *
Shock absorber
assembly
• Check operation and for oil
leakage.
• Replace if necessary.

23 *
Rear suspension
relay arm and
connecting arm
pivoting points
• Check operation. 
24 Engine oil
• Change (warm engine before
draining).
• Check oil level and vehicle for
oil leakage.
At the initial interval and when the oil change indicator flash-
es or comes on.

25
Eng
ine oil filter
cartridge
• Replace. 
26 * Cooling system
• Check coolant level and vehi-
cle for coolant leakage.

• Change. Every 3 years
27 * V-belt • Replace.
When the V-belt replacement indicator flashes [every 20000 km
(12000 mi)]
No. ITEM
CHECK OR MAINTENANCE
JOB
ODOMETER READINGS
ANNUAL
CHECK1000 km
(600 mi)
10000 km
(6000 mi)
20000 km
(12000 mi)
30000 km
(18000 mi)
40000 km
(24000 mi)