ASSEMBLING THE W INDROWER
Table 3.1 Engine Start Troubleshooting
Problem
Solution
Controls not
in NEUTRAL
• Move GSL to NEUTRAL
• Move steering wheel to locked position
• Disengage header clutch
Operator’s station not locked
• Adjust position of operator ’s station
• Ensure lock is engaged
Neutral int erlo ck misadjusted
• Refer to t h
e windrower technical manual
No fuel to
engine
• Fill empty fuel tank
• Replace clogged filter
• Ensure fuel shu t off valve is in open position
Old fuel in tank
•Draintank
•Refill with fresh fuel
Water, dir t, or air in fuel system
•Drain,flush, fill, and prime system
Improper type of fuel
•Usepr
oper fuel for operating conditions
Crankcase oil to o heavy
•Usere
commended oil
Low battery output
•Testt
he battery
•Check
battery electrolyte level
Poor battery connection
• Clean and tighten loose connections
Faulty starter
• Refer to the windrower technical manual
Wiring shorted, circuit breaker open
•Che
ck continuity of wirin g and breaker (manually reset)
Faulty injectors
• Refer to the windrower technical manual
147962 86 Revision A
To Next Page
Loading...
