CASTLE EP - Page 11

To Next Page

To Previous Page

67385867493098462 | en, eu, V5, 07. Oct 2016, page 11

Pic 2. The layout of main on-board elements of RS and PRO controllers

Main Page

Table of Contents2
Introduction7
Document Revision8
Controller Description and Package9
PCB Layout9
Controller Package12
Controller Specifications13
Controller Functions in Castle ACS15
Controller Installation. Overview16
Configuring the Controller16
Controller Power Supply17
Connecting Readers and Contactors. Overview18
General Rules for Connecting Contactless Card Readers18
Connecting Readers with Wiegand Interface20
Connecting Contactors and Touch Memory Readers21
Connecting Keypad Readers22
Important Notes on Non-Standard Readers22
Connecting the Communication Line and Setting up the Controller23
Connecting Ethernet Communication Line23
Setting Controller IP-Parameters23
Connecting RS485 Communication Line24
Setting RS485 Network Address26
Connecting Emergency Release Line26
The Use of General Purpose Outputs28
Reassigning Controller Terminals29
Connecting the Controller in Registration Board Mode30
Connecting Doors33
Connecting Two Doors. Overview33
Connecting Readers for Doors34
Connecting Door Locks. Overview34
Connecting Electromagnetic Locks or Latches35
Connecting Electromechanical Locks37
Connecting Other Types of Locks38
Example of Connecting the Lock with the Separate Control Input38
Connecting Electric Motor Locks40
Example of Connecting the Lock that Is too Far from the Controller41
Important Notes on the Use of Locks and Latches42
Connecting Door Opening Sensors43
Connecting RTE Buttons44
Connecting Door Blocking Buttons45
Example of Connecting Two Doors46
Connecting Card Capture Readers OMA-43.601, 43.606 for a Door46
Connecting Doorphones (Intercoms)47
Connecting Turnstiles49
Connecting Turnstiles. Overview49
Connecting a Turnstile Control Panel. Overview50
Connecting Turnstile Control Lines51
Connecting Readers for the Turnstile51
Connecting Card Capture Readers. Overview52
Connecting Card Capture Readers Kodos K-30, K-40, and K-10052
Connecting Elix PW-500 Card Capture Readers53
Connecting OMA-43.601, 43.606 Card Capture Readers for a Turnstile54
Connecting Rostov-Don KP1 Card Capture Reader55
Connecting ARGO and TVER56
Connecting Perco-IC03 Card Capture Reader57
Connecting Praktika K-01 Card Capture Reader58
Connecting Perco Turnstiles and Swing Gates59
Connecting Perco TTR-04.1, TTD-03, and T-5 Turnstiles60
Connecting Perco TTR-04N and TTR-04W-24 Turnstiles60
Connecting Perco RTD-03S Turnstile61
Connecting Perco RTD-15 Turnstile62
Connecting Perco TTR-04 Turnstile63
Connecting Perco TB-01 and TBC-01 Turnstiles64
Connecting Perco KT-02 and KT-05.3 IP-Stiles64
Connecting Perco T-04 Turnstile Stand65
Connecting Perco WHD-04 Swing Gate67
Connecting Perco WMD-05 Swing Gate67
Connecting Perco Turnstile Control Panel68
Connecting OMA Turnstiles70
Connecting OMA Turnstiles. Overview70
Connecting OMA Turnstiles with OMA-DD.958 and 264MS1 Controllers71
Connecting OMA Turnstiles with OMA 957 Controller72
Connecting OMA Turnstiles with OMA 956-3 and 956-4 Controllers73
Connecting OMA Turnstiles with OMA 956-1 and 956-2 Controllers73
Connecting the OMA-26.989U Turnstile Control Panel74
Connecting the OMA-DD.998 Turnstile Control Panel75
Connecting OMA Swing Gates. Overview75
Connecting Readers for OMA Swing Gate75
Setting Access Points for Operating with OMA 36.68 Swing Gate76
Connecting OMA 36.68 Swing Gate (OMA-DD.958 Controller)76
Connecting the OMA-26.989U Swing Gate Control Panel76
Connecting the OMA-DD.998 Swing Gate Control Panel77
Connecting Rostov-Don Turnstiles and Swing Gates; New Electronics77
Connecting Rostov-Don Turnstiles and Swing Gates; Old Electronics78
Connecting the Rostov-Don Turnstile Control Panel80
Connecting Gunnebo Glasstile Turnstiles80
Connecting Gunnebo DL600, Simplex, and Simplex ATT Turnstiles82
Connecting Tornello Turnstiles83
Connecting Stella STL -111 Turnstiles84
Connecting ARGO Turnstiles84
Connecting Fastlane Intelligate Passgate85
Connecting Readers for Fastlane Intelligate Passgate85
Setting Access Points for Operating with Fastlane Intelligate Passgate86
Connecting Fastlane Intelligate Passgate86
Connecting Gate and Barrier Drives87
Connecting Gates and Barriers. Overview87
Direct Control of Gate Drives89
Controlling a Third-Party Gate Controller (Control Unit)89
Connecting Readers for Gates90
Connecting the Gate Control Panel90
Connecting Vehicle Presence Sensors91
Connecting FAST, KRONO, ATI, and FERNI Drives92
Connecting FAAC Drives. Overview93
Connecting FAAC 596MPS and FAAC 610MPS Barriers94
Connecting FAAC 540BPR, 596BPR, and 615BPR95
Connecting FAAC 452MPS Gate Drives97
Connecting FAAC 740 and 741 Gate Drives99
Connecting FAAC Drives with 624BLD Control Unit100
Connecting NICE Barrier Drives. Overview102
Connecting NICE WIL4 and WIL6 Barriers102
Connecting NICE SIGNO Barriers104
Connecting NICE X-Bar Barriers and ROBUS Gate Drives105
Connecting Drives with A924 Control Unit107
Connecting CAME Drives. Overview108
Connecting Drives with ZL37 and ZL38 Control Units108
Connecting Drives with ZT4 Control Unit110
Connecting Drives with ZG2 Control Unit112
Connecting Drives with ZA3 Control Unit113
Connecting Drives with ZBK (ZBKE) Control Unit115
Connecting Drives with ZBX7 Control Unit117
Connecting Drives with ZC5 Control Unit119
Connecting Drives with ZL55 Control Unit120
Connecting Drives with ZL180 Control Unit122
Connecting BFT Drives. Overview124
Connecting Drives with ELMEC1 Control Unit124
Connecting GENIUS Barriers with A453 Control Unit125
Connecting GENIUS Drives with A382 Control Unit127
Connecting GENIUS Drives with LYNX 06 Control Unit128
Connecting a General Gate (Electric Motor and Two Starters)130
Connecting Hormann Drives. Overview131
Connecting Hormann Drives with A455 and B455 Control Units132
Connecting Hormann Drives with A460 and B460 Control Units133
Connecting O&O Drives with LOG-BT Control Unit135
Connecting Doorhan Drives. Overview136
Connecting Doorhan Barrier-5000136
Connecting Doorhan Drives with Control 144N Control Unit138
Connecting Doorhan SHAFT-30 Drives139
Connecting DEA Drives. Overview141
Connecting DEA Barriers with 124RR Control Unit141
Connecting Automatic Systems Drives142
Connecting Automatic Systems Barriers with BL12 Control Unit143
Connecting Automatic Systems Barriers with BL12 Control Unit. Limit Switch144
Connecting SEA Drives with MPU/0 Control Unit146
Connecting Bytec BAR-6 Barrier147
Connecting Marantec Drives with CS300 Control Unit149
Connecting Egate Barriers150
The Controller Operating Logic152
Starting the Controller152
Functioning of the Controller Power Supply Protection Circuits152
Functioning of the Reader Display Lines152
Processing Fire Alarm Signals153
Functioning of General Purpose Outputs153
Functioning of the Controller Input/Output Protection Circuits153
Reader Power Supply Circuits153
Controller Outputs153
Controller Inputs154
The Operating Logic in Two Door Configuration154
Working with Readers154
Working with RTE Buttons154
Working with Block Buttons155
The Operating Logic in Turnstile Configuration155
Working with a Turnstile155
Working with the Turnstile Control Panel156
The Operating Logic in Gate/Barrier Configuration157
Gate Operating Modes157
Direct Control of the Gate Drive157
Controlling a Third-Party Gate Controller157
Working with Readers158
Working with Manual Gate Control158
Working with Remote Keys158
Security Measures at Gate Automation159
Troubleshooting Techniques160
Troubleshooting Power Supply and Controller Start-Up160
Troubleshooting Ethernet Connection Quality160
Troubleshooting RS485 Connection Quality161
Troubleshooting Reader Connection161
Troubleshooting During Lock Connection162
Troubleshooting During Turnstile Connection162
Troubleshooting During Connection of Barriers and Gates165
Appendix 1. the Controller Audible Signals166
Appendix 2. the Controller LED Indication167
Appendix 3. the Controller Numeric Configuration Parameters168
Appendix 4. Summary for Cable Selection170
Appendix 5. Setting Controller RS485 Address171
Appendix 6. Encoding Characters on Keypad Reader173

CASTLE EP - Page 11

Table of Contents

Related product manuals